电场处理对GH3044合金腐蚀行为的影响

中国腐蚀与防护学报

2010, Vol. 30

Issue (2): 129-134

会议论文

本期目录 | 过刊浏览

电场处理对GH3044合金腐蚀行为的影响

刘杨;王磊;李伟涛;王富强

东北大学材料各向异性与织构教育部重点实验室沈阳 110819

EFFECTS OF ELECTRIC FIELD TREATMENT ON CORROSION BEHAVIOR OF GH3044 SUPERALLOY

LIU Yang; WANG Lei; LI Weitao; WANG Fuqiang

Key Laboratory for Anisotropy and Texture of Materials; Northeastern University; Shenyang 110819

全文: PDF(1745 KB)

摘要:

将电场处理技术应用于镍基变形高温合金GH3044，研究了电场对合金组织及腐蚀行为的影响。结果表明，电场处理后合金耐晶间腐蚀能力得到提高，随电场处理时间的延长腐蚀速率减小。在800℃、 6.4 kV/cm条件下，电场处理10 h后合金腐蚀速率为2.06 mm/a，与未经电场处理状态相比，降低幅度达37.33%。电场处理过程中合金晶内大量退火孪晶的产生，使原始大角度晶界与退火孪晶相交处原子重新排列，随电场处理时间的延长，大量的原始大角度晶界被取代，呈连续分布的合金元素贫化网络被隔断，导致腐蚀沟前进受到阻碍，从而改善合金晶界的腐蚀行为，提高合金耐晶间腐蚀能力。同时，电场处理促进合金中原子扩散，使普通大角度晶界两侧Cr、Mo等合金元素的贫化趋势降低，也是合金耐腐蚀性能得以改善的重要原因。

关键词 ：电场处理, 高温合金, 孪晶, 腐蚀

Abstract：

Electric field treatment was performed on one of nickel-base superalloy GH3044 and the effects of electric field treatment on the microstructure and corrosion behavior of the alloy were investigated. The results show that the intergranular corrosion resistance of the alloy is improved by the electric field treatment and the intergranular corrosion rate decreases with the increasing treatment time. The intergranular corrosion rate is 2.06 mm/a when the alloy is electric field treated under the condition of 800 ℃ and 6.4 kV/cm for 10 h, and the decreasing extent reaches 37.33 % compared with the alloy untreated. The formation of the annealing twins during the electric field treatment cause the redistribution of atoms of the crossings between the original high angle grain boundaries and the annealing twins. With the increase of electric field treated time, a large amount of original high angle grain boundaries are replaced and the continuous distribution of depletion network of the alloying element is separated, those lead to the retardation of the corrosion ditches to go forward. The intergranular corrosion resistance of the superalloy is improved due to the improving of intergranular corrosion behavior of the grain boundaries. Moreover, the promotion effect of electric field treatment on atom diffusion rate decrease the exhaustion tendency of Cr and Mo elements on both sides of normal high angle grain boundary. Those can be considered as the reasons of improving the corrosion resistance after electric field treatment.

Key words： electric field treatment superalloy twin corrosion

收稿日期: 2009-11-02

ZTFLH:

TG113.25

基金资助:

国家重点基础研究发展计划项目(2006CB605005)，国家自然科学基金项目(50841025)和长江学者和创新团队发展计划项目(IRT0731)资助

通讯作者: 王磊 E-mail: wanglei@mail.neu.edu.cn

Corresponding author: WANG Lei E-mail: wanglei@mail.neu.edu.cn

作者简介: 刘杨，男，1978年生，讲师，博士后，研究方向为高性能金属结构材料组织控制与强韧化

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	刘杨
44.8K

引用本文:

刘杨;王磊;李伟涛;王富强. 电场处理对GH3044合金腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2010, 30(2): 129-134.
LIU Yang. EFFECTS OF ELECTRIC FIELD TREATMENT ON CORROSION BEHAVIOR OF GH3044 SUPERALLOY. J Chin Soc Corr Pro, 2010, 30(2): 129-134.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y2010/V30/I2/129

[1] Zhang G Y, Zhang H, Wang Z S, et al. Oxidation behavior of NiAl-30.9Cr-3Mo-0.1Dy alloy at high temperature [J]. Rare Met.Mater. Eng., 2006, 35(5): 719-723
    (张光业，张华，王振生等. NiAl-30.9Cr-3Mo-0.1Dy合金的高温氧化行为 [J]. 稀有金属材料与工程，2006，35(5): 719-723)
[2] Zhao S Q, Xie X S. Hot corrosion behaviors of new Ni-Cr-Co base superalloy [J]. Mater. Sci. Technol., 2006, 14(5): 506-509
    (赵双群，谢锡善. 新型Ni-Cr-Co基高温合金的热腐蚀行为 [J]. 材料科学与工艺，2006，14(5): 506-509)
[3] Ahn S J, Rao S, Kwon H S, et al. Effects of PbO on the repassivation kinetics of alloy 690 [J]. Corros. Sci., 2006,48(5): 1137-1153
[4] Watanabe T, Tsurekawa S. Toughening of brittle materials by grain boundary engineering [J]. Mater. Sci.Eng., 2004, A387-389: 447-455
[5] Zhou Y, Aust K T, Erb U, et al. Effects of grain boundary structure on carbide precipitation in 304L stainless steel [J]. Scr. Mater., 2001, 45: 49-54
[6] Krupp U, Kane W M, Liu X Y, et al. The effect of grain-boundary-engineering-type processing on oxygen-induced cracking of IN718 [J]. Mater. Sci. Eng., 2003,A349: 213-217
[7] Wang L, Liu Y, Cui T, et al. Effects of electric-field treatment on a Ni-base superalloy [J]. Rare Met.,2007, 26(S1): 210-215
[8] Liu Y, Wang L, Ding Y, et al. Effects of electric field treatment on microstructure and deformation behavior of GH4199 superalloy [J]. Chin. J. Nonferrous Met., 2006,16(10): 1749-1752
    (刘杨，王磊，丁扬等. 电场处理对GH4199合金组织与变形行为的影响 [J]. 中国有色金属学报，2006，16(10): 1749-1752)
[9] Liu Y, Wang L, Qiao X Y, et al. Effects of strain rate on tensile deformation behavior of GH4199 superalloy after electric field treatment [J]. Rare Met. Mater. Eng., 2008,37(1): 66-72
    (刘杨，王磊，乔雪璎等. 应变速率对电场处理GH4199合金拉伸变形行为的影响 [J]. 稀有金属材料与工程，2008，37(1): 66-72)
[10] Liu Y, Wang L, Wang S, et al. Effects of electric field treatment on microstructures of GH4199 superalloy after long-term aging [J]. Trans. Nonferrous Met. Soc. China, 2006,16(S3): 1953-1957
[11] Wang L, Liu Y, Wang S, et al. Effects of electric field treatment on corrosion behavior of a Ni-Cr-W-Mo superalloy [J]. Mater. Trans., 2009, 50(7): 1644-1648

[1]	董续成, 管方, 徐利婷, 段继周, 侯保荣. 海洋环境硫酸盐还原菌对金属材料腐蚀机理的研究进展[J]. 中国腐蚀与防护学报, 2021, 41(1): 1-12.
[2]	唐荣茂, 朱亦晨, 刘光明, 刘永强, 刘欣, 裴锋. Q235钢/导电混凝土在3种典型土壤环境中腐蚀的灰色关联度分析[J]. 中国腐蚀与防护学报, 2021, 41(1): 110-116.
[3]	韩月桐, 张鹏超, 史杰夫, 李婷, 孙俊才. 质子交换膜燃料电池中TA1双极板的表面改性研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 125-130.
[4]	张雨轩, 陈翠颖, 刘宏伟, 李伟华. 铝合金霉菌腐蚀研究进展[J]. 中国腐蚀与防护学报, 2021, 41(1): 13-21.
[5]	冉斗, 孟惠民, 刘星, 李全德, 巩秀芳, 倪荣, 姜英, 龚显龙, 戴君, 隆彬. pH对14Cr12Ni3WMoV不锈钢在含氯溶液中腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2021, 41(1): 51-59.
[6]	左勇, 曹明鹏, 申淼, 杨新梅. MgCl₂-NaCl-KCl熔盐体系中金属Mg对316H不锈钢的缓蚀性能研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 80-86.
[7]	王欣彤, 陈旭, 韩镇泽, 李承媛, 王岐山. 硫酸盐还原菌作用下2205双相不锈钢在3.5%NaCl溶液中应力腐蚀开裂行为研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 43-50.
[8]	史昆玉, 吴伟进, 张毅, 万毅, 于传浩. TC4表面沉积Nb涂层在模拟体液环境下的电化学性能研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 71-79.
[9]	郑黎, 王美婷, 于宝义. 镁合金表面冷喷涂技术研究进展[J]. 中国腐蚀与防护学报, 2021, 41(1): 22-28.
[10]	于宏飞, 邵博, 张悦, 杨延格. 2A12铝合金锆基转化膜的制备及性能研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 101-109.
[11]	贾世超, 高佳祺, 郭浩, 王超, 陈杨杨, 李旗, 田一梅. 再生水水质因素对铸铁管道的腐蚀研究[J]. 中国腐蚀与防护学报, 2020, 40(6): 569-576.
[12]	赵鹏雄, 武玮, 淡勇. 空间分辨技术在金属腐蚀原位监测中的应用[J]. 中国腐蚀与防护学报, 2020, 40(6): 495-507.
[13]	马鸣蔚, 赵志浩, 荆思文, 于文峰, 谷义恩, 王旭, 吴明. 17-4 PH不锈钢在含SRB的模拟海水中的应力腐蚀开裂行为研究[J]. 中国腐蚀与防护学报, 2020, 40(6): 523-528.
[14]	岳亮亮, 马保吉. 超声表面滚压对AZ31B镁合金腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2020, 40(6): 560-568.
[15]	艾芳芳, 陈义庆, 钟彬, 李琳, 高鹏, 伞宏宇, 苏显栋. T95油井管在酸性油气田环境中的应力腐蚀开裂行为及机制[J]. 中国腐蚀与防护学报, 2020, 40(5): 469-473.

Viewed

Full text

Abstract

Cited

Shared

Discussed