微量稀土对HAl77-2铜合金组织及耐腐蚀性能的影响

中国腐蚀与防护学报

2010, Vol. 30

Issue (4): 262-268

研究报告

本期目录 | 过刊浏览

微量稀土对HAl77-2铜合金组织及耐腐蚀性能的影响

林高用,杨伟,万迎春,唐鹏钧,张胜华

中南大学材料科学与工程学院有色金属材料科学与工程教育部重点实验室长沙 410083

INFLUENCE OF TRACE RARE EARTH ELEMENTS ON MICROSTRUCTURE AND CORROSION RESISTANCE OF HAl77-2 COPPER ALLOY

LIN Gaoyong, YANG Wei, WAN Yingchun, TANG Pengjun, ZHANG Shenghua

Key Laboratory of Nonferrous Metals Materials Science and Engineering of Ministry of Education, School of Materials Science and Engineering, Central South University, Changsha 410083

全文: PDF(3947 KB)

摘要:

采用光学显微镜和常规力学性能测试分析了微量稀土对HAl77-2铝黄铜组织和力学性能的影响，结合静态腐蚀实验研究了添加稀土后合金耐腐蚀性能的变化，并利用扫描电镜、能谱分析和XRD等方法对腐蚀产物层进行了分析。结果表明：添加适量稀土可以使铝黄铜晶粒细化，强度提高，但塑性有所下降；在3.5%NaCl 溶液中，含稀土铝黄铜比不含稀土的铝黄铜耐蚀性能好，表面形成一层致密且与基体结合牢固的腐蚀产物层，其主要成分：内层为Al₂O₃和稀土氧化物，外层为 Cu、Zn的碱式氯化物和氯化物；而在3.5%NaCl+0.05%S^2-溶液中，添加稀土虽能改善腐蚀产物层结构，但膜层已被Cu₂S严重脆化，合金耐腐蚀性能反而略有下降。

关键词 ：稀土, HAl77-2合金, 组织, 耐腐蚀性能

Abstract：

Effects of trace rare earth (RE) elements on microstructure and mechanical properties of HAl77-2 Al-brass were analyzed by OM and conventional mechanical test. Static corrosion experiment was used to study the corrosion behavior of the Al-brass after adding RE addition and SEM, energy analysis and XRD were simultaneously used to investigate the corrosion product layer synthetically. It was demonstrated that adding RE to Al-brass could refine grain and increase strength, but decrease the elongation; The corrosion resistance of the RE-containing Al-brass was better than that of Al-brass without RE in NaCl (3.5 mass%) solution. The consequence of such good corrosion resistance was attributed to the formation of compact protective film on alloy surface which contained RE elements. The RE-contained film, which was composed of an inner Al₂O₃, RE oxide and an outer chloride or basic chloride of Cu, Zn, combined with the matrix firmly and was difficult to fall off from the alloy surface. While the addition of RE could not improve the corrosion resistance of Al-brass. in NaCl (3.5 mass%) +S^2- solution. Although the corrosion products layer was ameliorated due to the RE addition, the corrosion resistance of the alloy deteriorated yet owing to the severe embrittlement of the corrosion product layer caused by Cu₂S.

Key words： rare earth HAl77-2 alloy microstructure corrosion resistance

收稿日期: 2009-06-03

ZTFLH:

TG146.11

基金资助:

江苏省重大科技成果转化项目（DA2006034）和国家大学生创新性实验计划立项项目（081053309）资助

通讯作者: 林高用 E-mail: gylin1966@yahoo.com.cn

Corresponding author: LIN Gaoyong E-mail: gylin1966@yahoo.com.cn

作者简介: 林高用，男，1966年生，教授，研究方向为材料加工

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	杨伟
	林高用
44.8K

引用本文:

林高用,杨伟,万迎春,唐鹏钧,张胜华. 微量稀土对HAl77-2铜合金组织及耐腐蚀性能的影响[J]. 中国腐蚀与防护学报, 2010, 30(4): 262-268.
YANG Wei, LIN Gao-Yong. INFLUENCE OF TRACE RARE EARTH ELEMENTS ON MICROSTRUCTURE AND CORROSION RESISTANCE OF HAl77-2 COPPER ALLOY. J Chin Soc Corr Pro, 2010, 30(4): 262-268.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y2010/V30/I4/262

[1] Guo L, Li Y Q. Manufacturing Technique of Condenser Tube [M]. Beijing: Metallurgical Industry Press, 2007
    (郭莉, 李耀群. 冷凝管生产技术 [M]. 北京: 冶金工业出版社, 2007)
[2] Zhang S H, Huang Z Q. Influence of rare earth cerium on properties of HSn70-1 tin brass used for condenser tube [J]. Mater.Prot., 2006, 39(3): 62-65
    (张胜华, 黄政权. 稀土铈对冷凝管用锡黄铜组织和性能的影响 [J]. 材料保护,2006, 39(3): 62-65)
[3] Karpagavalli R, Balasubramaniam R.Development of novel brasses to resist dezincification [J]. Corros.Sci., 2007, 49: 963-979
[4] Liu Z C, Lin L Y, Liu S F. Dezincification corrosion behavior and its inhibiting mechanism of brass exposed to sea water [J]. Corros. Sci. Prot. Technol., 1999, 11(2): 78-83
    (刘增才, 林乐耘, 刘少锋. 实海暴露黄铜脱锌腐蚀行为及抑制脱锌机理研究 [J]. 腐蚀科学与防护技术, 1999, 11(2): 78-83)
[5] Sayed S M, Ashour E A, Youssef G I. Effect of sulfide ions on the corrosion behaviour of Al-brass and Cu10Ni alloys in salt water [J]. Mater. Chem. Phys. 2003,78:825-834
[6] Ravichandran R, Rajendran N. Electrochemical behaviour of brass in artificial seawater: effect of organic inhibitors [J].Appl. Surf. Sci., 2005, 241: 449-458
[7] Kabasakaloglu M, Kiyak T, Sendil O, et al. Electroche mical behavior of brass in 0.1 M NaCl [J]. Appl. Surf. Sci., 2002, 193: 167-174
[8] Li Y. An overview on the dezincification of brass [J]. Southern Met., 2005, 147: 15-18
    (李勇. 黄铜脱锌腐蚀的研究进展 [J]. 南方金属, 2005, 147: 15-18)
[9] Chen J L, Li Z, Zhao Y Y. Corrosion characteristic of Ce Al brass in comparison with As Al brass [J].Mater. Des., 2009, 30: 1743-1747
[10] Wang J H, Jiang X X, Li S Z. Corrosion wear behavior of copper alloys in 3.5 %NaCl+S^2- solutions [J]. J. Chin. Soc. Corros.Prot., 1997, 17(2): 81-86
     (王吉会, 姜晓霞, 李诗卓. 铜合金在3.5%NaCl+S^2-溶液中的腐蚀磨损行为 [J]. 中国腐蚀与防护学报, 1997, 17(2): 81-86)
[11] Wang J H, Jiang X X, Li S Z.Microstructure and properties of a new erosion-corrosion resistant brass [J]. Corros. Sci. Prot. Technol., 1998, 10(2): 11-16
     (王吉会, 姜晓霞, 李诗卓. 新型耐冲蚀黄铜的组织与性能 [J]. 腐蚀科学与防护技术, 1998, 10(2): 11-16)
[12] Wang J H, Jiang X X, Li S Z. Effect of boron on microstructure and corrosion resistance of aluminum brass [J]. Chin.J. Mater. Res., 1996, 10(6): 597-601
     (王吉会, 姜晓霞, 李诗卓. 硼对HAl77-2铝黄铜组织和腐蚀性能的影响 [J]. 材料研究学报, 1996, 10(6): 597-601)
[13] Tang N, Li Z, Cheng J Y,et al. Study of corrosion behavior of aluminum brass with rare earth in NaCl solution [J].Trans. Mater. Heat Treatment, 2007, 28(6): 104-108
     (唐宁, 李周, 程建奕等. 稀土铝黄铜在NaCl溶液中腐蚀行为的研究 [J].材料热处理学报, 2007, 28(6): 104-108)
[14] Cheng J Y, Li Z, Tang N, et al. Corrosion behavior of aluminum brass contained rare earth [J]. Chin. J. Nonferrous Met., 2007, 17(8): 1273-1279
     (程建弈, 李周, 唐宁等. 含稀土铝黄铜的腐蚀行为 [J]. 中国有色金属学报,2007, 17(8): 1273-1279)
[15] Li T B, Yan H H. Study on mechanism of corrosion of brass pipes in condenser [J]. Boiler Manuf.,2005: 64-66
     (李天彪, 颜河恒. 电厂凝汽器黄铜管腐蚀机理研究 [J]. 锅炉制造, 2005: 64-66)

[1]	韩月桐, 张鹏超, 史杰夫, 李婷, 孙俊才. 质子交换膜燃料电池中TA1双极板的表面改性研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 125-130.
[2]	史昆玉, 吴伟进, 张毅, 万毅, 于传浩. TC4表面沉积Nb涂层在模拟体液环境下的电化学性能研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 71-79.
[3]	王英君, 刘洪雷, 王国军, 董凯辉, 宋影伟, 倪丁瑞. 新型高强稀土Al-Zn-Mg-Cu-Sc铝合金的阳极氧化及其抗腐蚀性能研究[J]. 中国腐蚀与防护学报, 2020, 40(2): 131-138.
[4]	袁玮,黄峰,甘丽君,戈方宇,刘静. 显微组织对X100管线钢氢致开裂及氢捕获行为影响[J]. 中国腐蚀与防护学报, 2019, 39(6): 536-542.
[5]	付安庆,赵密锋,李成政,白艳,朱文军,马磊,熊茂县,谢俊峰,雷晓维,吕乃欣. 激光表面熔凝对超级13Cr不锈钢组织与性能的影响研究[J]. 中国腐蚀与防护学报, 2019, 39(5): 446-452.
[6]	欧阳跃军,胡婷,王佳音,谢治辉. 镁合金表面层状双氢氧化物的电化学沉积和表征[J]. 中国腐蚀与防护学报, 2019, 39(5): 453-457.
[7]	陈超,梁艳芬,梁天权,满泉言,罗毅东,张修海,曾建民. 稀土复合掺杂ZrO₂陶瓷涂层抗Na₂SO₄+NaVO₃热腐蚀性能的研究进展[J]. 中国腐蚀与防护学报, 2019, 39(4): 291-298.
[8]	史昆玉,张进中,张毅,万毅. Nb₂N涂层制备及其耐腐蚀性能研究[J]. 中国腐蚀与防护学报, 2019, 39(4): 313-318.
[9]	丰涵,宋志刚,吴晓涵,李惠,郑文杰,朱玉亮. 022Cr25Ni7Mo4N双相不锈钢选择性腐蚀行为与两相组织的关系研究[J]. 中国腐蚀与防护学报, 2019, 39(2): 138-144.
[10]	王凯, 易耀勇, 卢清华, 易江龙, 江泽新, 马金军, 张宇. 基于窄间隙焊接的热模拟峰值温度对Q690高强钢腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2018, 38(5): 447-454.
[11]	蒋光锐, 刘广会. Zn-Al-Mg合金的凝固组织及其耐腐蚀性能[J]. 中国腐蚀与防护学报, 2018, 38(2): 191-196.
[12]	牛振国, 郭浦山, 叶宏, 杨丽景, 许赪, 宋振纶. Zn-7Mg合金热处理显微组织演变及耐蚀性能研究[J]. 中国腐蚀与防护学报, 2017, 37(4): 347-353.
[13]	滕彧,陈旭,何川,王义闯,王冰. 显微组织对X70钢在含有硫酸盐还原菌的3.5%NaCl溶液中腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2017, 37(2): 168-174.
[14]	朱明,周嘏玥,张慧慧. 316不锈钢在添加微量稀土元素硝酸熔盐中腐蚀行为研究[J]. 中国腐蚀与防护学报, 2017, 37(1): 16-22.
[15]	耿振伟,肖代红. Zn对挤压态Mg-13Gd-2Cu合金的显微组织及腐蚀性能影响[J]. 中国腐蚀与防护学报, 2016, 36(6): 595-603.

Viewed

Full text

Abstract

Cited

Shared

Discussed