Mg-Li合金表面浅绿色超疏水复合膜层的制备及耐蚀性能研究

中国腐蚀与防护学报

2012, Vol. 32

Issue (4): 306-310

研究报告

本期目录 | 过刊浏览

Mg-Li合金表面浅绿色超疏水复合膜层的制备及耐蚀性能研究

侯文婷,康志新

华南理工大学机械与汽车工程学院国家金属材料近净成形工程技术研究中心广州 510640

PREPARATION OF GREENISH SUPER-HYDROPHOBIC DUPLEX-MODIFIED FILM ON Mg-Li ALLOY AND ITS CORROSION RESISTANCE

HOU Wenting, KANG Zhixin

National Engineering Research Center of Near-Net-Shape Forming for Metallic Materials, School of Mechanical & Automotive Engineering, South China University of Technology, Guangzhou 510640

全文: PDF(1244 KB)

摘要: 通过微弧氧化着色技术在Mg-Li合金表面生成浅绿色类陶瓷膜层，并在着色膜表面有机镀膜复合改性。用蒸馏水在镀膜表面的静态接触角以及动电位极化曲线和电化学阻抗谱测试，分别研究复合改性前后润湿性及耐蚀性。结果表明，微弧氧化着色表面通过有机镀膜生长了一层有机薄膜，接触角由近0°变为169.2°，实现了超亲水到超疏水的功能转化。Mg-Li合金基体经微弧氧化着色改性后，耐蚀性能明显提高，经复合改性后耐蚀性能进一步提高；与基体相比，超疏水复合膜在0.1 mol/L NaCl溶液中的动电位极化腐蚀电流密度减小3个数量级，电化学阻抗提高3个数量级。

关键词 ： Mg-Li合金, 微弧氧化着色, 有机镀膜, 复合表面改性, 超亲水, 超疏水, 耐蚀性

Abstract：Greenish analogous ceramic coating was obtained on the surface of Mg-Li alloy by micro-arc oxidation (MAO) coloring, then duplex modification was executed through polymer plating on the surface of MAO coloring film. The contact angle of distilled water, potentiodynamic polarization and electrochemical impedance spectroscopy (EIS) were used to characterize the wettability and corrosion resistance before and after duplex modification, respectively. The experimental results showed that the MAO coloring surface is covered by polymeric thin film through polymer plating, and it leads to the change of contact angle from nearly 0° to 169.2°, which indicates the wettability is modified from super-hydrophilic to super-hydrophobic. The MAO coloring film exhibits better corrosion resistance than bare Mg-Li alloy and its corrosion resistance is improved by duplex modification of polymer plating. Compared to bare Mg-Li alloy, the corrosion current density of super-hydrophobic duplex-modified film from potentiodynamic polarization decreases by three orders of magnitude and electrochemical impedance from electrochemical impedance spectroscopy increases by three orders of magnitude in 0.1 mol/L NaCl solution.

Key words： Mg-Li alloy micro-arc oxidation coloring polymer plating duplex surface modification super-hydrophilic super-hydrophobic corrosion resistance

收稿日期: 2011-05-30

ZTFLH:

TG174.4

基金资助:

广州市科技支撑计划项目(2009Z2-D811)资助

通讯作者: 康志新 E-mail: zxkang@scut.edu.cn

Corresponding author: KANG Zhixin E-mail: zxkang@scut.edu.cn

作者简介: 侯文婷，女，1987年生，硕士生，研究方向为金属材料表面改性

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	侯文婷
	康志新
44.8K

引用本文:

侯文婷,康志新. Mg-Li合金表面浅绿色超疏水复合膜层的制备及耐蚀性能研究[J]. 中国腐蚀与防护学报, 2012, 32(4): 306-310.
HOU Wen-Ting, KANG Zhi-Xin. PREPARATION OF GREENISH SUPER-HYDROPHOBIC DUPLEX-MODIFIED FILM ON Mg-Li ALLOY AND ITS CORROSION RESISTANCE. J Chin Soc Corr Pro, 2012, 32(4): 306-310.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y2012/V32/I4/306

[1] Jiang L, Wang R, Yang B, et al. Binary cooperative complementary nanoscale interfacial materials [J]. Pure Appl. Chem., 2000, 72(1-2): 73-81

[2] Nakajima A, Hashimoto K, Watanabe T. Recent studies on super-hydrophobic films [J]. Monatsh. Chem., 2001, 132(1): 31-41

[3] Yamashita H, Nakao H, Takeuchi M, et al. Coating of TiO₂ photocatalysts on super-hydrophobic porous teflon membrane by an ion assisted deposition method and their self-cleaning performance [J]. Nucl. Instrum. Meth., 2003, 206B: 898-901

[4] Kang Z X, Ye Q, Sang J, et al. Fabrication of super-hydrophobic surface on copper surface by polymer plating [J]. J. Mater. Process. Technol., 2009, 209(9): 4543-4547

[5] Song Y W, Shan D Y, Chen R S, et al. Corrosion characterization of Mg-8Li alloy in NaCl solution [J]. Corros. Sci., 2009, 51(5): 1087-1094

[6] Brunelli K, Dabala M, Calliari I, et al. Effect of HCl pre-treatment on corrosion resistance of cerium-based conversion coatings on magnesium and magnesium alloys [J]. Corros. Sci., 2005, 47(4): 989-1000

[7] Yerokhin A L, Nie X, Leyland A, et al. Plasma electrolysis for surface engineering [J]. Surf. Coat. Technol., 1999: 122(2-3): 73-93

[8] Zeng R C, Ke W, Xu Y B, et al. Recent development and application of magnesium alloys [J]. Acta Metall. Sin., 2001, 37(7): 673-685

    (曾荣昌, 柯伟, 徐永波等. 镁合金的最新发展及应用前景[J]. 金属学报, 2001, 37(7): 673-685)

[9] Kang Z X, Lai X M, Wang F, et al. Preparation of super-hydrophobic duplex-treated film on surface of Mg-Mn-Ce magnesium alloy and its corrosion resistance [J]. Chin. J. Nonferrous Met., 2011, 21(2): 283-289

   (康志新, 赖晓明, 王芬等. Mg-Mn-Ce镁合金表面超疏水复合膜层的制备及耐腐蚀性能 [J]. 中国有色金属学报, 2011, 21(2): 283-289)

[10] Kang Z X, Sang J, Shao M, et al. Polymer plating on AZ31 magnesium alloy surface and film evaluation of corrosion property [J]. J. Mater. Process. Technol., 2009, 209(9): 4590-4594

[11] Zhi Q, Gao J, Dong C F, et al. Corrosion behavior of microarc oxidation film on AZ91D magnesium alloy [J]. Acta Metall. Sin., 2008, 44(8): 986-990

     (郅青, 高瑾, 董超芳等. AZ91D镁合金微弧氧化膜的腐蚀行为研究 [J]. 金属学报, 2008, 44(8): 986-990)

[12] Zhang P, Nie X, Hu H, et al. TEM analysis and tribological properties of plasma electrolytic oxidation (PEO) coatings on a magnesium engine AJ62 alloy [J]. Surf. Coat. Technol., 2010, 205(5): 1508-1514

[13] Yan Y Y, Han Y, Li D C, et al. Effect of NaAlO₂ concentrations on microstructure and corrosion resistance of Al₂O₃/ZrO₂ coatings formed on zirconium by micro-arc oxidation [J]. Appl. Surf. Sci., 2010, 256(21): 6359-6366

[14] Lu S, Xu R Y, Chen J, et al. Optimization of silicate electrolyte for micro-arc oxidation and characteristic of coating fabricated on ZK60 magnesium alloy [J]. Chin. J. Nonferrous Met., 2010, 20(10): 1868-1875

     (芦笙, 徐荣远, 陈静等. ZK60镁合金微弧氧化硅酸盐电解液的优化及膜层特性 [J]. 中国有色金属学报, 2010, 20(10): 1868-1875)

[15] Guo P Y, Shao Y, Gao Y M, et al. Electrochemical impedance measurement on thermal grown oxide films of rare earth element Yb/Dy-modified Fe-Cr alloys [J]. J. Chin. Soc. Corros. Prot., 2010, 30(4): 317-322

     (郭平义, 邵雍, 高延敏等. Yb/Dy掺杂改性Fe-Cr合金热生长氧化膜的电化学阻抗谱研究 [J]. 中国腐蚀与防护学报, 2010, 30(4): 317-322)

[16] Wang Y H, Wang J, Zhang J B. Influence of micro-arc oxidation treatment on the corrosion behavior of AZ91D magnesium alloy [J]. J. Chin. Soc. Corros. Prot., 2006, 26(4): 216-220

     (王燕华, 王佳, 张际标. 微弧氧化处理对AZ91镁合金腐蚀行为的影响 [J]. 中国腐蚀与防护学报, 2006, 26(4): 216-220)

[17] Cao C N, Zhang J Q. Introduction to Electrochemical Impedance Spectroscopy [M]. Beijing: Science Press, 2002

     (曹楚南, 张鉴清. 电化学阻抗谱导论 [M]. 北京: 科学出版社, 2002)

[18] Ningshen S, Mudali U K, Amarendra G, et al. Hydrogen effects on the passive film formation and pitting susceptibility of nitrogen containing type 316L stainless steels [J]. Corros. Sci., 2006, 48(5): 1106-1121

[1]	黄鹏, 高荣杰, 刘文斌, 尹续保. 盐溶液刻蚀-氟化处理制备X65管线钢镀镍超双疏表面及其耐蚀性研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 96-100.
[2]	包任, 周根树, 李宏伟. 恒电位脉冲电沉积高锡青铜耐蚀镀层工艺研究[J]. 中国腐蚀与防护学报, 2020, 40(6): 585-591.
[3]	刘海霞, 黄峰, 袁玮, 胡骞, 刘静. 690 MPa级高强贝氏体钢在模拟乡村大气中的腐蚀行为[J]. 中国腐蚀与防护学报, 2020, 40(5): 416-424.
[4]	李聪玮, 杜双明, 曾志琳, 刘二勇, 王飞虎, 马付良. 电流密度对Ni-Co-B镀层微观结构及磨蚀性能的影响[J]. 中国腐蚀与防护学报, 2020, 40(5): 439-447.
[5]	曹京宜, 方志刚, 陈晋辉, 陈志雄, 殷文昌, 杨延格, 张伟. 5083铝合金表面单致密微弧氧化膜的制备及其性能研究[J]. 中国腐蚀与防护学报, 2020, 40(3): 251-258.
[6]	王英君, 刘洪雷, 王国军, 董凯辉, 宋影伟, 倪丁瑞. 新型高强稀土Al-Zn-Mg-Cu-Sc铝合金的阳极氧化及其抗腐蚀性能研究[J]. 中国腐蚀与防护学报, 2020, 40(2): 131-138.
[7]	王乐,易丹青,刘会群,蒋龙,冯春. Ru对Ti-6Al-4V合金腐蚀行为的影响及机理研究[J]. 中国腐蚀与防护学报, 2020, 40(1): 25-30.
[8]	武栋才,韩培德. 中温时效处理对SAF2304双相不锈钢耐蚀性的影响[J]. 中国腐蚀与防护学报, 2020, 40(1): 51-56.
[9]	孙晓光,韩晓辉,张星爽,张志毅,李刚卿,董超芳. 超低碳奥氏体不锈钢焊接接头耐腐蚀性及环保型化学钝化工艺研究[J]. 中国腐蚀与防护学报, 2019, 39(4): 345-352.
[10]	程多云,赵晋斌,刘波,姜城,付小倩,程学群. 高镍钢和传统耐候钢在马尔代夫严酷海洋大气环境中的腐蚀行为研究[J]. 中国腐蚀与防护学报, 2019, 39(1): 29-35.
[11]	蓝秀玲,刘光明,周街胜,刘志雷,彭叔森,李茂东. 有机硅/SiO₂杂化溶胶改性丙烯酸树脂及性能研究[J]. 中国腐蚀与防护学报, 2018, 38(6): 601-606.
[12]	蒋斌, 曾利兰, 梁涛, 潘浩波, 乔岩欣, 张竞, 赵颖. 316L不锈钢表面超疏水微纳镍镀层定向电沉积工艺优化研究[J]. 中国腐蚀与防护学报, 2018, 38(5): 438-446.
[13]	王志虎, 张菊梅, 白力静, 张国君. AZ91镁合金表面微弧氧化与化学镀铜复合处理层的微观组织与性能[J]. 中国腐蚀与防护学报, 2018, 38(4): 391-396.
[14]	杨钊, 时惠英, 蒋百灵, 葛延峰, 张静, 张曼玉, 李研. 脉冲电流对1050铝合金微弧氧化过程的影响[J]. 中国腐蚀与防护学报, 2018, 38(3): 283-288.
[15]	黄勇, 王善林, 王帅星, 龚玉兵, 柯黎明. 含硫化物夹杂铁基块体非晶合金在HCl溶液中的腐蚀行为[J]. 中国腐蚀与防护学报, 2018, 38(2): 203-209.

Viewed

Full text

Abstract

Cited

Shared

Discussed