H2S水溶液中的腐蚀与缓蚀作用机理的研究 Ⅲ.不同pH值H2S溶液中碳钢的腐蚀电化学行为

中国腐蚀与防护学报

2000, Vol. 20

Issue (2): 97-104

研究报告

本期目录 | 过刊浏览

H2S水溶液中的腐蚀与缓蚀作用机理的研究 Ⅲ.不同pH值H2S溶液中碳钢的腐蚀电化学行为

杨怀玉;陈家坚;曹楚南

中科院金属所金属腐蚀与防护国家重点实验室

Study on Corrosion and Inhibition Mechanism in H2S Aqueous Solutions 3.Electrochemical Behavior of Carbon Steel in the Different pH Solutions Containing H2S

Huiyu Yang;;;

中科院金属所金属腐蚀与防护国家重点实验室

全文: PDF(240 KB)

摘要: 利用极化曲线和阻抗技术,对低碳钢在不同pH值H2S溶液中的腐蚀电化学行为进行了研究.结果表明,在溶液pH值较低时,腐蚀电极主要受阳极酸性溶解过程控制,表面无硫化物沉积,其阻抗谱除高频容抗弧外,低频有一感抗存在;随pH的升高,腐蚀电位明显负移,电流密度减小,表面出现硫化物的不连续沉积,腐蚀因溶液pH值的增加和硫化物的沉积而减小,电极过程主要受硫化物的生长所控制;在pH值为6.2时,由于HS-的阴极去极化,腐蚀电流增加;当Ph大于7后,电极表面因氧化膜的生成而呈现钝化特征,极化电阻显著增加.基于溶液中HS-同OH-的竞争吸附,提出可能的腐蚀历程,据此可解释有关实验事实.

关键词 ：电化学阻抗谱, 极化曲线, 钝化, H2S溶液

Abstract：Electrochemical behavior of carbon steel in the simulated solutions containing H2S at different pH values have been investigated by potentiodynamic polarization curves and electrochemical impedance spectroscopy(EIS). The results indicated that at lower pH value, the electrode process of carbon steel was mainly controlled by anodic dissolution, the Nyquist diagrams were composed of a capacitive loop at high frequency and an inductive loop at the low frequency. With the increase in pH, the corrosion potential of carbon steel became more negative, as well as corrosion current density decreased. These changes could be attributed to the increase in pH and coverage of iron sulfide film, but a higher corrosion current was observed at pH 6.2, which was attributed to the depolarization of HS- in cathodic process. When the pH was higher than 7, the surface of corroding electrodes got into the stage of passivation because of the formation of iron oxide film. Based on the view of competitive adsorption between HS- and OH- on surface electrode, a probable reaction mechanism was suggested.

Key words： EIS potentiodynamic polarization passivation H2S solution

收稿日期: 1999-01-18

ZTFLH:

TG172

通讯作者: 杨怀玉

Corresponding author: Huiyu Yang

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	杨怀玉
	陈家坚
	曹楚南
44.8K

引用本文:

杨怀玉; 陈家坚; 曹楚南 . H2S水溶液中的腐蚀与缓蚀作用机理的研究 Ⅲ.不同pH值H2S溶液中碳钢的腐蚀电化学行为[J]. 中国腐蚀与防护学报, 2000, 20(2): 97-104 .
Huiyu Yang. Study on Corrosion and Inhibition Mechanism in H2S Aqueous Solutions 3.Electrochemical Behavior of Carbon Steel in the Different pH Solutions Containing H2S. J Chin Soc Corr Pro, 2000, 20(2): 97-104 .

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y2000/V20/I2/97

[1 ]刘小辉 .茂名石化公司炼油厂加工进口原油的设备腐蚀与防护 [J] 石油化工腐蚀与防护 ,1 994,( 4) :5 6
[2 ]FrenchEC .Corrosionandhydrogenblisteringcontrolinsourwatersystem [J].MaterialsPerformance ,1 978,( 3) :2 0 .
[3]HumphriesMJ ,SorellG .Corrosioncontrolincrudeoildistillationunits [J].MaterialsPerformance ,1 976 ,( 2 ) :1 3.
[4 ]BaumannC ,ScherrerC .Evalutionofinhibitorforcrudetoppingunits [J].MaterialsPerformance ,1 979,( 1 1 ) :5 1 .
[5 ]SardiscoJB ,PittsRE .CorrosionofironinanH2 S CO2 H2 OsystemcompositionandprotectivenessofthesulfidefilmasafunctionofpH[J].Corrosion ,1 96 5 ,2 1 ( 8) :35 0 .
[6 ]GuptaDVS .Corrosionbehaviorof 1 0 40carbonsteel [J].Corrosion ,1 981 ,37:6 1 1 .
[7]ShoesmithDW ,TaylorP ,BalleyMG ,OwenDG .Theformationofferrousmonosulfidepolymorphsduringthecorrosionofironbyaqueoushydrogensulfideat 2 1℃ [J].JElectrochemSoc ,1 980 ,1 2 7( 5 ) :1 0 0 7.
[8 ]杨怀玉 ,陈家坚 ,曹楚南 ,曹殿珍 H2 S水溶液中的腐蚀与缓蚀作用机理的研究 [J] 中国腐蚀与防护学报 ,2 0 0 0 ,2 0 ( 1 ) ;
[9]MorrisDR ,SampaleanuLP ,VeyseyDN .Thecorrosionofsteelbyaqueoussolutionsofhydrogensulfide [J].JElec trochemSoc ,1 980 ,1 2 7( 6 ) :1 2 2 8.
[1 0 ]曹楚南腐蚀电化学 [M].北京 :化学工业出版社 ,1 994 P1 0 4.
[1 1 ]HuangHH ,TsaiWT ,LeeJT .ElectrochemicalbehaviorofA5 1 6carbonsteelinsolutionscontaininghydrogensulfide[J].CorrosionScience ,1 994,36 ( 6 ) :1 0 2 7.
[1 2 ]IofaZA ,BatrakovVV ,Cho Ngok Ba .Influenceofanionadsorptionontheactionofinhibitorsontheacidcorrosionofironandcobalt [J].ElectrochimActa ,1 96 4 ,9:1 6 4 5 .
[1 3]ShoesmithDW ,TaylorP ,BaileyMG ,IkedaB .Electrochemicalbehaviorofironinalkalinesulphidesolutions [J].Electrochim .Acta ,1 978,2 3:90 3.
[1 4]ShoesmithDW ,BaileyMG ,IkedaB .Electrochemicalformationofmackinawiteinalkalinesulphidesolutions [J].ElectrochimActa ,1 978,2 3:1 32 9.
[1 5 ]SalvarezzaRC ,VidelaHA ,ArviaAJ .Theelectrodissolutionandpassivationofmildsteelinalkalinesulphidesolu tions [J].CorrosionScience ,1 982 ,2 2 ( 9) :81 5 .
[1 6 ]SalvarezzaRC ,VidelaHA ,ArviaAJ .Theelectrodissolutionbehaviorofmildsteelinphosphate borate sulphidesolu tions[J].CorrosionScience ,1 983,2 3( 7) :71 7.
[1 7]GeanaD ,MiligyAAEI,LorenzWJ .Electrochemicalbehaviorofironinalkalinesulphatesolutions [J].JApplElec trochem ,1 974,4:337.
[1 8]SmithmJS ,MillerJDA .Natureofsulphidesandtheircorrosiveeffectonferrousmetals :AReveiew[J].BrCorrosJ ,1 975 ,1 0 ( 3) :1 36 .
[1 9]VeraJ ,KapustaS ,HackermanN .Localizedcorrosionofironinalkalinesulfidesolutions [J].JElectrochemSoc ,1 986 ,1 33( 3) :46 1 .

[1]	冉斗, 孟惠民, 刘星, 李全德, 巩秀芳, 倪荣, 姜英, 龚显龙, 戴君, 隆彬. pH对14Cr12Ni3WMoV不锈钢在含氯溶液中腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2021, 41(1): 51-59.
[2]	史昆玉, 吴伟进, 张毅, 万毅, 于传浩. TC4表面沉积Nb涂层在模拟体液环境下的电化学性能研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 71-79.
[3]	李子运, 王贵, 罗思维, 邓培昌, 胡杰珍, 邓俊豪, 徐敬明. 热带海洋大气环境中EH36船板钢早期腐蚀行为研究[J]. 中国腐蚀与防护学报, 2020, 40(5): 463-468.
[4]	胡露露, 赵旭阳, 刘盼, 吴芳芳, 张鉴清, 冷文华, 曹发和. 交流电场与液膜厚度对A6082-T6铝合金腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2020, 40(4): 342-350.
[5]	孙硕, 杨杰, 钱薪竹, 常人丽. Ni-Cr-P化学镀层的制备与电化学腐蚀行为[J]. 中国腐蚀与防护学报, 2020, 40(3): 273-280.
[6]	何壮,王兴平,刘子涵,盛耀权,米梦芯,陈琳,张岩,李宇春. 316L和HR-2不锈钢在盐酸液膜环境中的钝化与点蚀[J]. 中国腐蚀与防护学报, 2020, 40(1): 17-24.
[7]	张瑞,李雨,关蕾,王冠,王福雨. 热处理对激光选区熔化Ti6Al4V合金电化学腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2019, 39(6): 588-594.
[8]	孙晓光,韩晓辉,张星爽,张志毅,李刚卿,董超芳. 超低碳奥氏体不锈钢焊接接头耐腐蚀性及环保型化学钝化工艺研究[J]. 中国腐蚀与防护学报, 2019, 39(4): 345-352.
[9]	王霞,任帅飞,张代雄,蒋欢,古月. 豆粕提取物在盐酸中对Q235钢的缓蚀性能[J]. 中国腐蚀与防护学报, 2019, 39(3): 267-273.
[10]	达波,余红发,麻海燕,吴彰钰. 等效电路拟合珊瑚混凝土中钢筋锈蚀行为的电化学阻抗谱研究[J]. 中国腐蚀与防护学报, 2019, 39(3): 260-266.
[11]	严少坤,郑大江,韦江,宋光铃,周廉. 钝性纯Ti在人工海水中的电化学活化行为研究[J]. 中国腐蚀与防护学报, 2019, 39(2): 123-129.
[12]	丰涵,宋志刚,吴晓涵,李惠,郑文杰,朱玉亮. 022Cr25Ni7Mo4N双相不锈钢选择性腐蚀行为与两相组织的关系研究[J]. 中国腐蚀与防护学报, 2019, 39(2): 138-144.
[13]	达波,余红发,麻海燕,吴彰钰. 阻锈剂的掺入方式对全珊瑚海水混凝土中钢筋锈蚀的影响[J]. 中国腐蚀与防护学报, 2019, 39(2): 152-159.
[14]	刘东,向红亮,刘春育. 含Ag抗菌双相不锈钢表面腐蚀产物的XPS分析[J]. 中国腐蚀与防护学报, 2018, 38(6): 533-542.
[15]	刘明,程学群,李晓刚,卢天健. 低合金钢筋在水泥萃取液中钝化膜的耐蚀机理研究[J]. 中国腐蚀与防护学报, 2018, 38(6): 558-564.

Viewed

Full text

Abstract

Cited

Shared

Discussed