NaCl液膜下碳钢腐蚀速率及其与环境因素的关联性

中国腐蚀与防护学报

2010, Vol. 30

Issue (1): 67-71

研究报告

本期目录 | 过刊浏览

NaCl液膜下碳钢腐蚀速率及其与环境因素的关联性

唐子龙^1;2;李超¹;李辉¹

1. 天津大学材料科学与工程学院天津 300072
2. 天津大学天津市材料复合与功能化重点实验室天津 300072

CORROSION RATE OF CARBON STEEL UNDER LIQUID LAYER CONTAINING Cl^-AND ITS CORRELATION WITH ENVIRONMENT CONTROL FACTORS

TANG Zilong^1;2; LI Chao¹; LI Hui¹

1．School of Materials Science and Engineering; Tianjin University; Tianjin 300072
2．Tianjin Key Laboratory of Composite and Functional Materials; Tianjin University; Tianjin 300072

全文: PDF(628 KB)

摘要:

用磁阻探头技术研究1 mmol/L NaCl液膜下碳钢腐蚀行为的磁信号特征，以IFA (Integration Filter Algorithm)算法计算潮湿时间内平均腐蚀速率。提出多因素关联分析的数据标准化方案，并根据线性模型分析平均腐蚀速率随浸润时间、温度和相对湿度的变化关系。用多种电化学技术研究Q235钢在1 mmol/L、\linebreak5 mmol/L及10 mmol/L的NaCl溶液中的腐蚀动力学，计算自腐蚀电流和极化阻力等电化学参数。结果表明，浸润时间和相对湿度(RH)跟平均腐蚀速率呈负相关；温度跟平均腐蚀速率呈正相关。各因素对潮湿期平均腐蚀速率影响的大小次序是相对湿度>温度>浸润时间。温度和相对湿度分别在24 ℃和RH70%左右对平均腐蚀速率的影响存在转折点。

关键词 ：大气腐蚀, 薄液膜, 数据标准化, 原位测量, 关联性

Abstract：

Corrosion behavior of carbon steel under NaCl liquid layer is investigated by inductive resistance probe(IRP). Average corrosion rate over the wet period, short for IFACR, is calculated by integration filter algorithm (IFA) with controlled environment factors including time of immersion (TOI), temperature and relative humidity (RH). A data-standardization approach is proposed in order to improve the accuracy of correlation of IFACR with the 3 control factors modeled by a linear equation. Two sets of corrosion kinetics parameters, corrosion current density I_corr, polarization resistance and anodic and cathodic Tafel constants, of Q235 steel in 1，5，10 mmol/L NaCl are measured by various electrochemical techniques including polarization curve, dynamic potential scan and potential step with an intention to benefit the understanding of corrosion under thin liquid layer. The results indicate that temperature has positive correlation with IFACR and TOI and RH show negative correlation. The contribution of RH to IFACR is maximum among three control factors, TOI is minimum and temperature is in middle. A changed contribution to IFACR of the factors, around 24 ℃ and RH 70% called threshold, is identified and specified. Also, this threshold is consistent with that of TOW (Time of Wetness) measurements done previously. The roles of Cl^- in the changed contribution and the specific threshold are analyzed. The detailed discussion on the dependences of IFACR and total corrosion loss on TOI, temperature and RH is presented with the help of electrochemical measurements.

Key words： atmospheric corrosion thin liquid layer data standardization in-situ measurement correlation

收稿日期: 2008-12-01

ZTFLH:

TG174.1

基金资助:

国家自然科学基金项目(50671072)资助

通讯作者: 唐子龙 E-mail: zlt633@gmail.com

Corresponding author: TANG Zilong E-mail: zlt633@gmail.com

作者简介: 唐子龙，男，1968年生，副教授。研究方向为腐蚀电化学、腐蚀信息学和表面改性

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	唐子龙
	李超
	李辉
44.8K

引用本文:

唐子龙;李超;李辉. NaCl液膜下碳钢腐蚀速率及其与环境因素的关联性[J]. 中国腐蚀与防护学报, 2010, 30(1): 67-71.
TANG Zi-Long, LI Tiao, LI Hui. CORROSION RATE OF CARBON STEEL UNDER LIQUID LAYER CONTAINING Cl^-AND ITS CORRELATION WITH ENVIRONMENT CONTROL FACTORS. J Chin Soc Corr Pro, 2010, 30(1): 67-71.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y2010/V30/I1/67

[1] Nishimura T. Rust formation and corrosion performance of Si- and Al-bearing ultrafine grained weathering steel [J]. Corros.Sci., 2008, 50(4): 1306-1312
[2] Frankel G S, Stratmann M, Rohwerder M. Potential control under thin aqueous layers using a Kelvin probe [J]. Corros. Sci., 2007, 49(4): 2021-2036
[3] Cole I S, Ganther W D, Sinclair J D. A study of the wetting of metal surfaces in order to understand the processes controlling atmospheric corrosion [J]. J.Electrochem. Soc., 2004, 151(12): B627-B635
[4] Monnier J, Legrand L,Bellot-Gurlet L. Study of archaeological artefacts to refine the model of iron long-term indoor atmospheric corrosion [J]. J. Nucl.Mater., 2008, 379: 105-111
[5] Tang Z L, Song X, Zhang Y P. Control factors of time of wetness and IRP corrosion rate of Q235 steel under pure water thin liquid film [J]. J. Chin. Soc. Corros.Prot.，2009，29(3): 161-166
    (唐子龙, 宋鑫, 张义萍.纯水薄液膜下Q235钢潮湿时间的影响因素和腐蚀速度的磁阻研究 [J].中国腐蚀与防护学报, 2009， 29(3): 161-166)
[6] Refait Ph, Abdelmoula M, Genin J M R. Mechanisms of formation and structure of green rust one in aqueous corrosion of iron in the presence of chloride ions [J]. Corros, Sci., 1998, 40(9): 1547-1560
[7] Costa J M, Llorente J, Vilarrasa M. Atmospheric corrosion: Field study of metals runoff [A]. Proceedings of the 14th International Corrosion Congress [C]. Cape Town, 1999: 36
[8] Corvo F, Minotas J, Delgado J, et al. Changes in atmospheric corrosion rate caused by chloride ions depending on rain regime [J]. Corros. Sci., 2005, 47(4): 883-892
[9] Gamal A E. Atmospheric corrosion of copper under wet/ dry cyclic conditions [J]. Corros. Sci., 2005, 47(6): 1370-1383
[10] Evgin, Tiefnig [P]. U.S. Pat. 5583426, 1996
[11] Tang Z L, Song S Z. Numeric analysis of inductive resistance probe and application in atmospheric corrosion [J]. J. Chem. Ind. Eng., 2007，58(3): 698-703
     (唐子龙, 宋诗哲. 磁阻探头系统腐蚀速率解析及在大气腐蚀中的应用 [J].化工学报，2007，58(3): 698-703)
[12] Stratmann M, Hoffmann K. In situ Mobauer spectroscopic study of reactions within rust layers [J]. Corros. Sci., 1989, 29(11): 1329-1352
[13] Tang Z L, Chao L, Qu W C, et al. Correlation between the control factors and time of wetness of Q235 Steel under Cl^-, SO₄^2-and CO₃^2-contaminants liquid film [J]. J. Chin. Soc. Corros. Prot., in press.
     (唐子龙, 李超, 曲文超等.污染离子对Q235钢潮湿时间的多因素关联性分析 [J]. 中国腐蚀与防护学报，待发表)

[1]	范益,陈林恒,蔡佳兴,代芹芹,马宏驰,程学群. 热轧AH36船板钢在室内仓储条件下的腐蚀行为研究[J]. 中国腐蚀与防护学报, 2020, 40(1): 10-16.
[2]	潘成成,马超,夏大海. EBSD技术研究金属材料晶体取向对大气腐蚀萌生的影响机理[J]. 中国腐蚀与防护学报, 2019, 39(6): 495-503.
[3]	赵晋斌,赵起越,陈林恒,黄运华,程学群,李晓刚. 不同表面处理方式对300M钢在青岛海洋大气环境下腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2019, 39(6): 504-510.
[4]	邓俊豪,胡杰珍,邓培昌,王贵,吴敬权,王坤. 氧化皮对SPHC热轧钢板在热带海洋大气环境中初期腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2019, 39(4): 331-337.
[5]	孙永伟,钟玉平,王灵水,范芳雄,陈亚涛. 低合金高强度钢的耐模拟工业大气腐蚀行为研究[J]. 中国腐蚀与防护学报, 2019, 39(3): 274-280.
[6]	王力, 郭春云, 肖葵, 吐尔逊·斯拉依丁, 董超芳, 李晓刚. Q235和Q450钢在吐鲁番干热大气环境中长周期暴晒时的腐蚀行为研究[J]. 中国腐蚀与防护学报, 2018, 38(5): 431-437.
[7]	林修洲, 杨丽, 梅拥军, 郑兴文, 罗淑文, 崔学军. 飞机起落架镀镉4130钢在甲酸钾溶液薄液膜下腐蚀电化学行为研究[J]. 中国腐蚀与防护学报, 2017, 37(6): 567-574.
[8]	王军, 冯超, 彭碧草, 谢亿, 张明华, 吴堂清. S450EW焊接接头在NaHSO₃溶液中的腐蚀行为研究[J]. 中国腐蚀与防护学报, 2017, 37(6): 575-582.
[9]	张新新,高志明,胡文彬,伍志鹏,韩连恒,卢丽花,修妍,夏大海. Q235钢在薄液膜下腐蚀行为与图像信息的相关性研究[J]. 中国腐蚀与防护学报, 2017, 37(5): 444-450.
[10]	张鑫,戴念维,杨燕,张俊喜. 模拟工业环境下直流电场对金属Zn腐蚀机理的影响[J]. 中国腐蚀与防护学报, 2017, 37(5): 451-459.
[11]	孟晓波,蒋武斌,廖永力,李锐海,郑志军,高岩. 输电杆塔材料在模拟工业环境中的大气腐蚀行为研究[J]. 中国腐蚀与防护学报, 2017, 37(5): 460-466.
[12]	赵苇杭, 王浩伟, 蔡光义, 董泽华. AA6061铝合金在含盐薄液膜下的局部腐蚀与缓蚀机理[J]. 中国腐蚀与防护学报, 2017, 37(4): 366-374.
[13]	孙霜青,郑弃非,李春玲,王秀民,胡松青. 腐蚀产物对纯Al 8A06长期大气腐蚀行为影响的研究[J]. 中国腐蚀与防护学报, 2017, 37(2): 110-116.
[14]	白子恒,黄运华,李晓刚,杨浪,董超芳,颜利丹,肖葵. 硫硼酸阳极氧化处理的7050铝合金在工业海洋大气中的腐蚀行为[J]. 中国腐蚀与防护学报, 2016, 36(6): 580-586.
[15]	李东亮,付贵勤,朱苗勇. 湿热工业海洋大气中Si对桥梁钢腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2016, 36(5): 433-440.

Viewed

Full text

Abstract

Cited

Shared

Discussed