Please wait a minute...
中国腐蚀与防护学报  2013, Vol. 33 Issue (4): 317-324    
  研究报告 本期目录 | 过刊浏览 |
脉冲电沉积高速Ni工艺研究
张午花 费敬银 骆立立 林西华
西北工业大学理学院 西安 710129
High Speed Pulse Electro Plating Process of Nickel
ZHANG Wuhua, FEI Jingyin, LUO Lili, LIN Xihua
School of Science, Northwestern Polytechnical University, Xi’an 710129, China
全文: PDF(5760 KB)  
摘要: 研究了高速Ni镀液在脉冲电沉积条件下,工艺参数对Ni镀层的沉积速率、内应力、孔隙率及微观形貌等方面的影响规律。结果表明,温度、平均电流密度、频率、逆向脉冲系数及占空比对镀层性能和微观形貌有较大影响。与常规电沉积Ni方法相比,脉冲电沉积高速Ni还具有高效、节能等特点。
关键词 脉冲电沉积镀镍高速电镀    
Abstract:The influences of pulse electroplating parameters on deposition rate, internal stress, porosity and microstructure of high speed nickel coating were studied. The results showed that the temperature, average current density, frequency, reverse pulse coefficient and duty cycle had great impact on the microstructure of coatings. Compared with the conventional method of electrodeposition of nickel, high speed pulse electrodeposition of nickel had the advantages of high efficiency, energy saving and so on.
Key wordspulse electrodeposition    nickel plated    high speed plating
    
ZTFLH:  TG153  

引用本文:

张午花, 费敬银, 骆立立, 林西华. 脉冲电沉积高速Ni工艺研究[J]. 中国腐蚀与防护学报, 2013, 33(4): 317-324.
ZHANG Wuhua, FEI Jingyin, LUO Lili, LIN Xihua. High Speed Pulse Electro Plating Process of Nickel. Journal of Chinese Society for Corrosion and protection, 2013, 33(4): 317-324.

链接本文:

https://www.jcscp.org/CN/      或      https://www.jcscp.org/CN/Y2013/V33/I4/317

[1] Ciszewski A, Posluszny S, Milczarek G, et al. Effects of saccharin and quaternary ammonium chlorides on the electrodeposition of nickel from a Watts-type electrolyte [J]. Surf. Coat. Technol., 2004, 183: 127-133
[2] Kendrick R J, Watson S A. Bath and method for electroforming and electrodepositing nickel [P]. U.S. Pat., 3326782, 1967
[3] Lin C S, Hsu P C, Chang L, et al. Properties and microstructure of nickel electrodeposited from a sulfamate bath containing ammonium ions [J]. J. Appl. Electrochem., 2001, 31: 925-933
[4] Zeng Y P, Li Y G, Tang X Y, et al. The effect of reverse pulse plating technology on the internal stress of electrodeposited nickel coatings [J]. Plat. Finish., 1992, 14(3): 22-25
(曾燕屏, 李友国, 唐祥云等. 换向脉冲电镀工艺对镀镍层应力的影响 [J]. 电镀与精饰, 1992, 14(3): 22-25)
[5] Zhou Y J, Man H N. The method of internal stress’s produce and eliminate in electroplating layer [J]. Coat. Paint. Electroplat., 2005, 3(3): 13-16
(周英杰, 满红娜. 电镀层内应力的产生和消除方法 [J]. 涂料涂装与电镀, 2005, 3(3): 13-16)
[6] Hui B P, Fei J Y, Xin W L, et al. Behavior of hydrogen permeation in Zn-Ni alloy electrodeposition [J]. Plat. Finish., 2006, 28(2): 10-13
(惠百平, 费敬银, 辛文利等. Zn-Ni合金电沉积过程中的渗氢行为 [J]. 电镀与精饰, 2006, 28(2): 10-13)
[7] Wan X J. Hydrogen embrittlement of metal [J]. Mater. Prot., 1979,12(2/3): 11-25
(万晓景. 金属的氢脆 [J]. 材料保护, 1979, 12(2/3): 11-25)
[8] Tang P T, Leisner P, Moller P. Improvement of nickel deposit characteristics by pulse plating [A]. AESF SUR/FIN'93 [C]. Anaheim, 1993: 249-256
[9] Fei J Y, Ma Z Y. Brush plating hydrogen embrittlement and its prevention [J]. Surf. Technol., 2001, 30(3): 38-40
(费敬银, 马宗耀. 电刷镀氢脆及防止措施 [J]. 表面技术, 2001, 30(3): 38-40)
[10] El-Sherik A M, Erb U, Page J. Microstructural evolution in pulse plated nickel electrodeposits [J]. Surf. Coat. Technol., 1996, 88: 70-78
[11] Mishra R, Basu B, Balasubramaniam R. Effect of grain size on the tribological behavior of nanocrystalline nickel [J]. Mater. Sci. Eng., 2004, A373: 370-373
[12] Shen Y F, Xue W Y, Wang Y D, et al. Mechanical properties of nanocrystalline nickel films deposited by pulse plating [J]. Surf. Coat. Technol., 2008, 202: 5140-5145
[13] Tóth-Kádár E, Bakonyi I, Pogány L, et al. Microstructure and electrical transport properties of pulse-plated nanocrystalline nickel electrodeposits [J]. Surf. Coat. Technol., 1996, 88, 57-65
[14] Fei J Y, Wilcox G D. Electrodeposition of Zn-Co alloys with pulse containing reverse current [J]. Electrochim. Acta, 2005, 50, 2693-2698
[15] Stoney G G. The tension of metallic films deposited by electrolysis [J]. Proc. Roy. Soc., 1909, 82: 172-175
[16] Li Y F. Measurement of internal stress of electroplating coatings [J]. Surf. Technol., 1981, (1): 26-34
(李云峰. 电镀层内应力的测量 [J]. 表面技术, 1981, (1): 26-34)
[17] Kang J X, Zhao W Z, Xu Y G, et al. Effect of technology parameters on rate electrodeposition of nanocrystalline nickel [J]. Trans. Mater. Heat Treat., 2008, 29(3): 152-155
(康进兴, 赵文珍, 徐英鸽等. 工艺参数对电沉积纳米晶镍沉积速率的影响 [J]. 材料热处理学报, 2008, 29(3): 152-155)
[18] Yuan X T, Wang Y, Sun D B, et al. Influence of pulse parameters on the microstructure and micrehardness of nickel electrodeposits [J]. Surf. Coat. Technol., 2008, 202: 1895-1903
[19] Fei J Y, Liang G Z, Xia W L. Electrodeposition of compositionally modulated zinc-cobalt alloy multilayer coatings [J]. Chin. J. Chem. Eng., 2005, 13(2): 259-265
[20] Abdulin V S, Chernenko V I. The current efficiency and mechanical properties of nickel deposited in a pulse mode [J]. Zashch.Met., 1982, 18(6): 964-966
[21] Bakonyi I, Tóth-Kádár E, Pogány L, et al. Preparation and characterization of d.c.-plated nanocrystalline nickel electrodeposits [J]. Surf. Coat. Technol., 1996, 78(1-3): 124-136
[1] 黄鹏, 高荣杰, 刘文斌, 尹续保. 盐溶液刻蚀-氟化处理制备X65管线钢镀镍超双疏表面及其耐蚀性研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 96-100.
[2] 丁诗炳,项腾飞,李澄,郑顺丽,王绮,杜梦萍. 两步法制备超疏水耐蚀镍镀层[J]. 中国腐蚀与防护学报, 2016, 36(5): 450-456.
[3] 刘阳,华小珍,黄晋华,崔霞,周贤良,俞应炜. SiC表面化学镀镍对SiCp/Al复合材料界面及耐蚀性影响[J]. 中国腐蚀与防护学报, 2016, 36(2): 130-136.
[4] 陈叶,费敬银,王磊,万冰华. 脉冲电沉积法制备高P镍基合金镀层[J]. 中国腐蚀与防护学报, 2012, 32(6): 501-506.
[5] 李均明,薛晓楠,王爱娟,马安博,符致昭. 镁合金微弧氧化预处理化学镀镍研究[J]. 中国腐蚀与防护学报, 2012, 32(1): 23-27.
[6] 彭成章,朱玲玲. 热处理对Ni-P/纳米Al2O3复合镀层组织及耐腐蚀性能的影响[J]. 中国腐蚀与防护学报, 2011, 31(3): 179-183.
[7] 刘丽红,张子华,闫杰,苏少燕. 化学镀镍磷合金在海洋环境中的腐蚀行为[J]. 中国腐蚀与防护学报, 2010, 30(5): 369-373.
[8] 姜莉莉; 李谋成; 张文麒; 沈嘉年 . 纳米晶镀锌层在3.5%NaCl溶液中的腐蚀电化学行为[J]. 中国腐蚀与防护学报, 2008, 28(5): 303-306 .
[9] 杨黎晖; 李峻青; 姜巍巍; 赵雪松; 张密林 . 镁锂合金化学镀镍工艺[J]. 中国腐蚀与防护学报, 2008, 28(3): 177-180 .
[10] 王春雨; 武高辉; 苟华松; 康鹏超 . Gr/Al复合材料表面化学镀镍沉积特性及耐蚀性[J]. 中国腐蚀与防护学报, 2008, 28(3): 141-145 .
[11] 郑臻; 余新泉; 孙扬善; 薛烽; 任世科 . 前处理对镁合金化学镀镍结合力的影响[J]. 中国腐蚀与防护学报, 2006, 26(4): 221-226 .
[12] 霍宏伟; 李瑛; 王福会 . AZ91D镁合金化学镀镍[J]. 中国腐蚀与防护学报, 2002, 22(1): 14-17 .
[13] 胡文彬; 向阳辉; 刘新宽 . 镁合金化学镀镍预处理过程表面状况的研究[J]. 中国腐蚀与防护学报, 2001, 21(6): 340-344 .
[14] 韩克平;方景礼;武勇;张敏;王健红. 胱氨酸加速化学沉积镍的机理[J]. 中国腐蚀与防护学报, 1996, 16(2): 81-86.