防锈油膜失效之前的电位变化

中国腐蚀与防护学报

2000, Vol. 20

Issue (5): 312-316

研究简报

本期目录 | 过刊浏览

防锈油膜失效之前的电位变化

钟庆东

上海市上海电力学院电化学室

POTENTIAL VARIATION OF RUST PREVENTING OIL FILM BEFORE ITS DEGRADATION

Qingdong Zhong;

上海市上海电力学院电化学室

全文: PDF(114 KB)

摘要: 采用丝束电极研究防锈失效之前的电位变化.结果表明,防锈油膜失效之前,涂油丝束电极腐蚀电位在(-0.2～0.3V VS SCE )范围内分布,呈现一定程度的不均匀性.防锈油膜失效之前,涂油丝束电极腐蚀电位随着浸泡时间而发生变化,在浸泡初期,随着浸泡时间的延长,腐蚀电位分布发生一定程度的正移,当腐蚀电位分布达到最大值时,随着浸泡时间的延长,腐蚀电位则服从不连续二项分布.随着浸泡时间的延长,涂油丝束电极腐蚀电位从正态分布向不连续二项分布转变.

关键词 ：防锈油, 电化学测量, 丝束电极

Abstract：Potential variation of rust prevention oil film after its degradation was studied by using wire beam electrode.In this paper,potential variation of rust preventing oil film before its degradation was studied using wire beam electrode.It has been found that the distribution of corrosion potential on the surface of oil-coated wire-beam electrode os heterogeneous before the degradation of rust preventing oul film. At the early stage of immersion, The distribution of corrosion potential gradually shifts to a higher potential range with increasing of immersion time.When the distribution of corrodion potential reaches to a highest potential range,it begins to shift negatively to a lower potential range.Ir is suggested that thes situation may be due to metal corrosion taking place at the metal/coating interface.The distribution of corrosion potential on oil-painted wire-beam electrode follows a normal probability distribution before the degradation of oil coating. With increasing of immersion time. the distribution of corrosion potential on oil-painted wire-beam electrode may change from normal probability distribution before the degradation of oil coating to discintinuous binomial distribution after the degradation of oil coating

Key words： rust preventing oil electrochemical measurement wire beam electrode

收稿日期: 1999-09-09

ZTFLH:

TG174.4

通讯作者: 钟庆东

Corresponding author: Qingdong Zhong

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	钟庆东
44.8K

引用本文:

钟庆东 . 防锈油膜失效之前的电位变化[J]. 中国腐蚀与防护学报, 2000, 20(5): 312-316 .
Qingdong Zhong. POTENTIAL VARIATION OF RUST PREVENTING OIL FILM BEFORE ITS DEGRADATION. J Chin Soc Corr Pro, 2000, 20(5): 312-316 .

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y2000/V20/I5/312

[1]蒋汉瀛,钟庆东,舒余德等.采用丝束电极研究防锈油膜的防护性能[J].中国腐蚀与防护学报,1996,16(4):298-302
[2] Zhong Q D. Electrochemical technique for investigating temporarily protective oil coating [J].Prog.Org.Coat.,1997,30(4):279-283
[3]左禹.非晶态NeCrFeSiB合金孔蚀萌生期间的电流波动[J].中国腐蚀与防护学报,1995,15(1):28-34
[4]钟庆东.有机涂膜电化学不均匀性及涂膜下金属腐蚀机理研究[D].湖南长沙:中南工业大学博士学位论文,1996
[5]钟庆东.防锈油膜失效期间的电位波动现象[J].中国腐蚀与防护学报,1997,17(4):281-285
[6] Wolstenholme J. Electrochemical methods of assessing the corrosion of painted metals-a review[J].Corrosion Sci., 1973,13:521-530

[1]	陈洁净,鞠虹,孙灿,李霞,刘雲飞. 电化学测试技术在垢下腐蚀中的应用[J]. 中国腐蚀与防护学报, 2017, 37(3): 207-215.
[2]	程庆利,陶彬,刘栓,刘全桢,张卫华,田松柏,王立平. 原油沉积水对Q235B碳钢的腐蚀影响[J]. 中国腐蚀与防护学报, 2017, 37(2): 126-134.
[3]	张彭辉, 王燕华, 彭欣, 刘在健, 周媛媛, 王佳. 采用丝束电极技术研究液滴下Cu腐蚀行为[J]. 中国腐蚀与防护学报, 2014, 34(5): 459-464.
[4]	陈碧, 郑碧娟, 张帆, 刘宏芳. 静磁场下硫酸盐还原菌对HSn70-1铜合金的腐蚀行为[J]. 中国腐蚀与防护学报, 2014, 34(4): 339-345.
[5]	刘圆圆,王伟,王燕华,王佳. NaCl液滴下304不锈钢表面电化学性质研究[J]. 中国腐蚀与防护学报, 2012, 32(1): 28-33.
[6]	王雷, 董俊华, 柯伟. 加载与循环干湿条件作用下对MnCu耐候钢的腐蚀行为[J]. 中国腐蚀与防护学报, 2010, 30(4): 257-261.
[7]	胡金丰; 李国希; 邓恺; 刘洋 . 用丝束电极研究混凝土中钢筋腐蚀的不均匀性[J]. 中国腐蚀与防护学报, 2005, 25(2): 88-92 .
[8]	闫茂成; 翁永基 . 环境溶液对管道钢应力腐蚀过程电化学行为的影响[J]. 中国腐蚀与防护学报, 2005, 25(1): 34-38 .
[9]	翁永基 . 用丝束电极(WBE)评价不锈钢在NaCl溶液中点蚀敏感性[J]. 中国腐蚀与防护学报, 2003, 23(6): 326-329 .
[10]	钟庆东; 谢巧敏; 周国定 . 防锈油膜腐蚀电位分布的不均匀性[J]. 中国腐蚀与防护学报, 2001, 21(4): 206-209 .
[11]	钟庆东; 谢巧敏; 周国定 . 模糊聚类分析评价防锈油膜电化学不均匀性[J]. 中国腐蚀与防护学报, 2000, 20(6): 368-373 .
[12]	黄桂芳; 吴翠兰; 靳九成 . 防锈油防护性能的影响因素及油膜下金属腐蚀特征[J]. 中国腐蚀与防护学报, 1999, 19(3): 179-184 .
[13]	钟庆东 . 采用丝束电极研究金属的缝隙腐蚀*[J]. 中国腐蚀与防护学报, 1999, 19(3): 189-192 .
[14]	钟庆东;舒余德;蒋汉瀛. 防锈油膜失效期间的电位波动现象[J]. 中国腐蚀与防护学报, 1997, 17(4): 281-285.
[15]	蒋汉瀛;钟庆东;舒余德;吴翠兰. 采用丝束电极研究防锈油膜的防护性能[J]. 中国腐蚀与防护学报, 1996, 16(4): 298-302.

Viewed

Full text

Abstract

Cited

Shared

Discussed