不同水工况下超临界机组水冷壁管材料的腐蚀特性研究

doi:10.11902/1005.4537.2013.137

中国腐蚀与防护学报

2014, Vol. 34

Issue (3): 243-248 DOI: 10.11902/1005.4537.2013.137

本期目录 | 过刊浏览

不同水工况下超临界机组水冷壁管材料的腐蚀特性研究

朱志平(

), 陆海伟, 汤雪颖, 焦晓翠, 于卫卫

长沙理工大学化学与生物工程学院长沙 410114

Corrosion Characteristics of 15CrMoG Steel a Supercritical Unit Water-wall Tube Material in Waters of Different Water Chemistry

ZHU Zhiping(

), LU Haiwei, TANG Xueying, JIAO Xiaocui, YU Weiwei

School of Chemical and Biological Engineering, Changsha University of Science & Technology, Changsha 410114, China

全文: PDF(2611 KB) HTML

摘要:

利用OM,SEM/EDS和XRD等测试手段,研究了模拟还原性全挥发处理 (AVT(R)) 和给水加氧处理 (OT) 工况下Cl^-及Cl^-/SO₄^2-对超临界机组水冷壁管材料15CrMoG的腐蚀特性的影响。结果表明：在 AVT(R) 工况下试片表面氧化物颗粒比OT工况更为均一且分布均匀；在含Cl^-或Cl^-/SO₄^2-模拟OT溶液工况中,试片腐蚀程度随离子浓度增大而增大。在相同离子浓度的OT工况溶液中试片的腐蚀程度比AVT(R) 更严重,且在同一工况下相同离子浓度的Cl^-/SO₄^2-比Cl^-侵蚀性强。由于点蚀的自催化作用,在模拟AVT(R) 和OT工况溶液中试片均会发生严重局部腐蚀。EDS结果表明,两种工况不同离子溶液中试片的点蚀坑内均未发现Cl^-,但测得S的含量与水冷壁管成分相比显著增高。

关键词 ：还原性全挥发处理, 给水加氧处理, 阴离子, 水冷壁管材料

Abstract：

The corrosion characteristics of 15CrMoG steel a supercritical unit water-wall tube material in two kinds of waters were studied by means of metallography, SEM/EDS, and XRD etc. The two waters aim to simulate the boiler water after the all-volatile treatment (reduction) and the oxygenated treatment, i.e. all-volative treatment (reduction) (ATV(R)) water and oxygenated treatment (OT) water respectively. The results showed that a much uniform oxide scale with much uniform particles size distribution grew on the steel surface under the AVT(R) condition rather than that under OT condition. The corrosion degree of the steel increased in the OT water with addition of Cl^- or Cl^-/SO₄^2- with increasing ion concentrations. At the same ion concentration, the corrosion of the steel under the simulated OT condition was more severe than that under AVT(R) condition and the Cl^-/SO₄^2- was more corrosive than Cl^- under the same condition. Due to autocatalytic effect of pitting corrosion, serious local corrosion occurred on the steel in the simulated AVT(R) and OT waters. It is noted that Cl^- was not detected but an obvious S content was detected by EDS in the pits on the steel surface under the two conditions with different ion in waters.

Key words： all-volative treatment (reduction) oxygenated treatment anion water-wall tube material

收稿日期: 2013-08-28

ZTFLH:

TG174.1

基金资助:湖南省自然科学基金项目(09JJ6067);湖南省科技攻关项目(2010GK3171)资助

作者简介: null

朱志平，男，1963年生，教授，博士，研究方向为锅炉水处理技术、电力(热力)设备腐蚀与防护

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	朱志平
	陆海伟
	汤雪颖
	焦晓翠
	于卫卫
44.8K

引用本文:

朱志平, 陆海伟, 汤雪颖, 焦晓翠, 于卫卫. 不同水工况下超临界机组水冷壁管材料的腐蚀特性研究[J]. 中国腐蚀与防护学报, 2014, 34(3): 243-248.
Zhiping ZHU, Haiwei LU, Xueying TANG, Xiaocui JIAO, Weiwei YU. Corrosion Characteristics of 15CrMoG Steel a Supercritical Unit Water-wall Tube Material in Waters of Different Water Chemistry. Journal of Chinese Society for Corrosion and protection, 2014, 34(3): 243-248.

链接本文:

https://www.jcscp.org/CN/10.11902/1005.4537.2013.137 或 https://www.jcscp.org/CN/Y2014/V34/I3/243

图1

图2

图3

图4

图5

图6

图7

图8

[1]	Zhu Z P,Sun B D,Li Y C. Water Chemical Condition and Optimization of A Utility Boiler[M]. Beijing: China Electric Power Press,2009
[1]	(朱志平,孙本达,李宇春. 电站锅炉水化学工况及优化[M]. 北京: 中国电力出版社, 2009)
[2]	Wang G R. Optimization of operation condition of chemical water system in 660 MW ultra supercritical unit[J]. Huadian Technol., 2012, 34(6): 5-8
[2]	(王国蓉. 660MW超超临界机组化学水工况优化[J]. 华电技术, 2012, 34(6): 5-8)
[3]	Gu Q H, Fu Y. Practice of oxygen-adding treatment for feed-water of once-through boilers equipped for supercritical units in guohuataicang power plant[J]. Therm. Power Gener., 2009, 38(12): 92-94, 97
[3]	(顾庆华, 付昱. 国华太仓发电厂超临界机组直流锅炉给水加氧处理实践[J]. 热力发电, 2009, 38(12): 92-94, 97)
[4]	Jing L L, Zhu Z P, Zhang H, et al. Study of the pyrolytic characteristics of power-plant-purposed cation exchange resin[J]. J. Eng. Therm. Energy Power, 2012, 27(1): 96-100
[4]	(荆玲玲, 朱志平, 张辉等. 电厂用阳离子交换树脂高温分解特性研究[J]. 热能动力工程, 2012, 27(1): 96-100)
[5]	Jing L L, Zhu Z P, Xiong S H, et al. The study on sulfate leaching properties of cation exchange resin used in condensate polishing system[J]. Ion Exch. Adsorpt., 2011, 27(5): 435-443
[5]	(荆玲玲, 朱志平, 熊书华等. 凝结水精处理阳树脂硫酸根溶出特性研究[J]. 离子交换与吸附, 2011, 27(5): 435-443)
[6]	Sang J Z, Wang X P, Li H, et al. Problems and precautionary measures of ion exchange resin in water treatment during operation[J]. Hebei Electric Power, 2009, 28(1): 43-44
[6]	(桑俊珍, 王晓攀, 李红等. 水处理用离子交换树脂运行中存在的问题及预防措施[J]. 河北电力技术, 2009, 28(1): 43-44)
[7]	Xu J Y, Cao S A, Lou T F, et al. Pitting corrosion of Cl- on carbon steel in aqueous solutions[J]. North China Electric Power, 2001, (11): 17-19
[7]	(许金莹, 曹顺安, 楼台芳等. 高温炉水中Cl-对20号碳钢点蚀试验研究[J]. 华北电力技术, 2001, (11): 17-19)
[8]	Tang Z M, Hu S L, Zhang P Z. Stress corrosion cracking of 316Ti in 300 ℃ high temperature water containing chloride ions[J]. J. Chin. Soc. Corros. Prot., 2012, 32(4): 291-295
[8]	(唐占梅, 胡石林, 张平柱. 316Ti在含氯离子300 ℃高温水中的应力腐蚀开裂[J]. 中国腐蚀与防护学报, 2012, 32(4): 291-295)
[9]	Fu J Q, Wang L C, Ding H R, et al. Problems of sulfate radical in the water-steam system of nuclear units and ultra-supercritical units[J]. J. Shanghai Univ. Electric Power, 2010, 26(6): 581-584
[9]	(傅洁琦, 王罗春, 丁桓如等. 核电机组和超超临界机组水汽系统中的SO42-问题[J]. 上海电力学院学报, 2010, 26(6): 581-584)
[10]	DL/T 805.4-2004. Guideline for cycle chemistry in fossil plants Part 4: Feedwater treatment[S]
[10]	(DL/T 805.4-2004. 火电厂汽水化学导则第4部分: 锅炉给水处理[S])
[11]	DL/T 805>.1-2011. Guideline for cycle chemistry in fossil plant Part 1: Oxygenated treatment for feed-water system of boiler[S]
[11]	(DL/T 805.1-2011. 火电厂汽水化学导则第1部分: 锅炉给水加氧处理导则[S])

[1]	王娜娜, 王锋涛, 常亮, 朱志平. 锅炉补给水中典型有机物分解规律及其对低压缸叶片腐蚀特性研究[J]. 中国腐蚀与防护学报, 2017, 37(6): 597-604.
[2]	王青, 马雪梅, 石海燕, 原珊, 郭建峰, 梁栋, 胡志勇. 苯并咪唑衍生物在1 mol/L HCl溶液中对45^#碳钢缓蚀行为的研究[J]. 中国腐蚀与防护学报, 2015, 35(1): 49-54.
[3]	刘彤, 张艳飞, 陈旭, 王丹, 陈宇, 王冠夫. SRB对X70钢在土壤模拟溶液中腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2014, 34(2): 112-118.
[4]	赵景茂 . 三种缓蚀性阴离子对碳钢在NaHCO3-NaCl溶液中点蚀的抑制作用[J]. 中国腐蚀与防护学报, 2004, 24(3): 174-178 .
[5]	许淳淳; 吴小梅 . 几种阴离子对AISI 304不锈钢孔蚀的影响[J]. 中国腐蚀与防护学报, 2003, 23(3): 129-133 .
[6]	王海涛; 赵景茂; 左禹 . 几种阴离子对316L不锈钢亚稳态孔蚀行为的影响[J]. 中国腐蚀与防护学报, 2002, 22(4): 202-206 .
[7]	许淳淳; 傅晓萍; 刘幼平 . 几种有机阴离子的电迁移及其对闭塞区的影响[J]. 中国腐蚀与防护学报, 2001, 21(1): 26-31 .
[8]	左禹; 陆玉成; 熊金平 . 几种阴离子对亚稳态孔蚀行为的影响*[J]. 中国腐蚀与防护学报, 1999, 19(1): 21-26 .

Viewed

Full text

Abstract

Cited

Shared

Discussed