用旋转圆盘—圆环电极研究黄铜的阳极溶解

中国腐蚀与防护学报

1982, Vol. 2

Issue (3): 1-9

研究报告

本期目录 | 过刊浏览

用旋转圆盘—圆环电极研究黄铜的阳极溶解

邹津耘;甘复兴;柳传忠;姚禄安

武汉大学电化学研究室;武汉大学电化学研究室;武汉大学电化学研究室;武汉大学电化学研究室

STUDY OF ANODIC DISSOLUTION OF BRASS USING ROTATING RING DISC ELECTRODE

Zou Jinyun Gan Fuxing Liu Chuanzhong and Yao Luan (The Electrochemistry Laboratory; Wuhan University)

全文: PDF(833 KB)

摘要: 本文采用旋转圆盘——圆环电极研究了黄铜(Cu37Zn)在1N Na_2SO_4及0.5N NaCl溶液中的阳极溶解行为。分别测出了黄铜阳极溶解时铜和锌的阳极溶解分电流密度。实验结果表明,Cu37Zn在上述两种介质中阳极溶解时均存在脱锌现象。在1N Na_2SO_4溶液中测得的脱锌系数强烈地依赖于阳极电位,而在0.5N NaCl溶液中,其脱锌系数与阳极电位的关系不明显。由黄铜中铜和锌的阳极极化曲线外推计算出了黄铜阳极溶解时锌和铜的腐蚀分电流密度,在1N Na_2SO_4溶液中分别为0.089及3×10~(-5)μA/cm~2,在0.5N NaCl溶液中分别为3.6及1.6μA/cm~2。实验还表明,黄铜在上述介质中的阳极溶解过程由扩散步骤所控制。

Abstract：The behavior of anodie dissolution of brass(Cu37Zn)was investigated in 1N Na_2SO_4 and 0.5N NaCl solutions with rotating ring-disc electrode. Partial anodic current densities of zinc and copper dissolution(i_(Zn) and i_(Cn)) of brass were measured respectively. Experimental results show that dezincification of Cu37Zn takes place in above mentioned media during anodic dissolution. Calculated dezincification factor of Cu37Zn Varies with electrode potential in 1N Na_2SO_4 solution. However, this factor does not vary significantly with electrode potential in 0.5N NaCl solution. By extrapolation of the partial polarization curves of copper and zinc for Cu37Zn, partial corros on current densities of zinc and copper have been calculated as follows: i_(corr)(Cu) i_(corr)(Zn) 1N Na_2SO-4 3×10~(-5)μA/cm~2 0.089μA/cm~2 0.5N NaCl 1.6μA/cm~2 3.6μA/cm~2 Experimental results also show that the rate of anodie dissolution of brass is mass-diffusion-controlled in both investigated media.

收稿日期: 1982-06-25

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	邹津耘
	甘复兴
	柳传忠
	姚禄安
44.8K

引用本文:

邹津耘;甘复兴;柳传忠;姚禄安. 用旋转圆盘—圆环电极研究黄铜的阳极溶解[J]. 中国腐蚀与防护学报, 1982, 2(3): 1-9.
. STUDY OF ANODIC DISSOLUTION OF BRASS USING ROTATING RING DISC ELECTRODE. J Chin Soc Corr Pro, 1982, 2(3): 1-9.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y1982/V2/I3/1

[1] H. Sugawara, H. Ebiko, Corr. Sci., 7, 513(1967)
[2] R. H. Heidershach, E. Verink, Corrosion, 28, 397(1972)
[3] 西安热工所,防止凝汽器铜管的腐蚀和破裂工作总结.(1975)
[4] 山东工学院,凝汽器用黄铜管腐蚀行为的实验考查(1975)
[5] H. G. Feller, Corr. Sci, 8． , 259(1968)
[6] G. Jeseph, M. T. Arce, Corr., Sci, 7, 597(1967)
[7] R. Natarajan, P, C. Angele, Corrosion, 31． 302(1975)
[8] 西安热工所.α-黄铜试验室快速脱锌腐蚀试验方法的探讨,(1975)
[9] B. Miller. J. Electrochem. Soc., 116, 1117(1969)
[10] B. Miller et al. ibid, 9, 1510(1972)
[11] H. W. Pickering, P. J. Byrne ibid, 6． 1492(1969)
[12] H. W. Pickering ibid, 7． 8(1970)
[13] #12
[14] #12
[15] #12
[16] 邹津耘、柳传忠、姚禄安,材料保护,4,16(1980)
[17] W. J. Albery, M. L. Hitcuman, "Ring-disc Electrode" Oxford University Press, London, (1971)

No related articles found!

Viewed

Full text

Abstract

Cited

Shared

Discussed