由Na_2SO_4沉积引起的高温合金B—1900在中温下的热腐蚀

中国腐蚀与防护学报

1990, Vol. 10

Issue (4): 275-286

研究报告

本期目录 | 过刊浏览

由Na_2SO_4沉积引起的高温合金B—1900在中温下的热腐蚀

张允书;李连方;石声泰

中国科学院上海冶金研究所;中国科学院上海冶金研究所;中国科学院上海冶金研究所

Na_2SO_4 INDUCED HOT CORROSION OF B- 1900 SUPERALLOY AT INTERMEDIATE TEMPERATURES

Zhang Yunshu Li Lianfang Shih Shengtai (shanghai Institute ot Metallurgy;Acadmia Sinica)

全文: PDF(2362 KB)

摘要: 用涂 Na_2SO_4盐膜法研究高温合金 B-1900在827℃和750℃于空气中的热腐蚀行为,测定其腐蚀动力学曲线,用 X -射线衍射和电子探针元素面扫描方法分析腐蚀产物的相组成和成份,还对其中的水溶性离子进行化学定量分析。实验结果表明,Na_2SO_4沉积能引起 B-1900合金在中等温度下的热腐蚀,且腐蚀行为是灾难性的。基于实验结果,提出了 B-1900合金在中温下的热腐蚀机理。认为 MoO_3(可能以 Mo_2O_7~(2-)和 Mo_3O_(10)~(2-)形式)参与电化阴极还原反应。MoO_3和 MoO_3~(2-)在熔盐层中的相对迁移将 O_2的还原移至熔盐/空气交界面进行,从而导致快速热腐蚀的发生。熔盐中的 Na_2SO_4与MoO_3反应生成的 SO_3导致了熔盐的高酸度和合金内硫化,进一步加剧了热腐蚀的进程

Abstract：Hot corrosion behavior of Na)2SO_4 coated B-1900 alloy was studied in air at 827 and 750℃.Corrosion kinetics of the coated alloy was gravimetrically measured,and contents of water soluble ions in the reaction products were chemically analyzed.X-ray diffraction and EMP techniques were employed to determine the components and morphology of the corrosion product scale.The experimental results indicate that B-1900 alloy is subject to catastrophic oxidation when covered with Na)2SO_4,and that the hot corrosion is related to the formation of molten Na_2SO_4-Na_2MoO_4-MoO_3 salt on the alloy surface.On the basis of experimental results a corrosion mechanism is proposed for the Na_2SO_4 induced hot corrosion of B-1900 alloy at intermediate temperat- ures.MoO_3(probably as Mo_2O~(2-)_7or Mo_3O~(2-)_(10))is believed to take part in the reduction reaction.The countertransport of MoO_3 and MoO~(2-)_3in the meit carries the reduction reaction of oxygen to the scale (melt)/air interface,which is responsible for the rapid corrosion.The high acidity of the melt and internal sulfidation of the alloy caused by SO_3 resulting from the reaction of Na_2SO_4 with MoO_3 enhance rapid hot corrosion.

收稿日期: 1990-08-25

基金资助:科学院腐蚀科学开放研究实验室课题;;国家自然科学基金委员会重大项目资助

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张允书
	李连方
	石声泰
44.8K

引用本文:

张允书;李连方;石声泰. 由Na_2SO_4沉积引起的高温合金B—1900在中温下的热腐蚀[J]. 中国腐蚀与防护学报, 1990, 10(4): 275-286.
. Na_2SO_4 INDUCED HOT CORROSION OF B- 1900 SUPERALLOY AT INTERMEDIATE TEMPERATURES. J Chin Soc Corr Pro, 1990, 10(4): 275-286.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y1990/V10/I4/275

[1] Coebel,J.A.;Pettit,F.S.and Goward,G.W.,Metall.Trans.,4,261 (1973)
[2] Fryburg,G.C,;Kohl,F.J.;Stearns,C.A.and Fielder,E.L.,J.Electrochem.Soc.,129,571 (1982)
[3] Misra,A.K.,Oxid.Met.,25,129 (1968)
[4] Misra,A.K.,J.Electrochem.Soc.,133,1029,1038(1986)
[5] Bourhis,Y.and St.John,C,,in “Properties of High Temperature Alloys”,Foroulis,Z.A.and Pettit,F.S.,Eds.,p 595,The Electrochem.Soc.,Princeton,N.J.(1976)
[6] Weast,R.C.,in “Handbook of Chemistry and Physics”,Chemical Rubber Co.,Cleveland,Ohio(1977)
[7] Blander,M.,in “Molten Salt Chemistry”,P 127,John Wiley,New York (1964)
[8] Darken,L.S.and Gurry,R.W.,in “Physical Chemistry of Metals”,McGraw-Hill,New York (1953)
[9] Janz,C.J.,in “Molten Salt Handbook”,Academic Press,New York(1967)
[10] Arkel,A.E.V.;Flood,E.A.and Bright,N.F.H.,Can.J.Chem.,31,1009(1953)

No related articles found!

Viewed

Full text

Abstract

Cited

Shared

Discussed