渗铝涂层对Ni_3Al-Mo基合金高温氧化的防护作用及机理

中国腐蚀与防护学报

1995, Vol. 15

Issue (2): 87-92

研究报告

本期目录 | 过刊浏览

渗铝涂层对Ni_3Al-Mo基合金高温氧化的防护作用及机理

叶长江;李铁藩;张亚明;毛晓禹

中国科学院金属腐蚀与防护研究所腐蚀科学开放实验室;暨南大学物理系

INVESTIGATION ON ALUMINIZED COATING ON DS Ni_3Al-Mo BASE ALLOY

Ye Changjiang; Li Tiefan; Zhang Yaming; Mao Xiaoyu (Corrosion Science Lab.; Institute of Corrosion and Protection of Metals; Chinese Academy of Sciences)(Physics Department of Jinan University)

全文: PDF(2005 KB)

摘要: 采用高活度渗铝工艺在ＩＣ－６（Ｎｉ３Ａｌ－Ｍｏ基）合金表面获得内扩散型渗铝涂层，在氮气环境下对渗铝涂层进行扩散处理．利用光学显微镜、ＳＥＭ、ＥＰＭＡ、ＸＲＤ分析研究了涂层的成分及组织结构，测定表明，涂层中的钼以Ｍｏ３Ａｌ沉淀相的形式存在．等温氧化及循环氧化实验表明，渗铝涂层的抗高温氧化性能明显优于ＩＣ－６合金；保护性的Ａｌ２Ｏ３氧化膜阻止了钼的氧化物的形成，避免了ＩＣ－６合金在循环氧化中出现的ＮｉＭｏＯ４相的多晶型转变，显著改变了合金的抗循环氧化能力；涂层经１０００℃、３００ｈ等温氧化及１０００℃、１００ｈ循环氧化后，未出现β－ＮｉＡｌ相的分解，可认为涂层具有较强的保护作用。

关键词 ：ＩＣ－６合金, 渗铝涂层, Ｍｏ_３Ａｌ相

Abstract：Ni3Al-Mo base alloy IC-6 was aluminized by high activity process and the specimen was subsequentlydiffusion treated under argon atmosphere. The microstructure and chemical composition of the coatingwas investigated by optical microscopy, XEM, EPMA and XRD. It was found that molybdenum in thecoating is present as a second phase Mo3Al. The oxidation resistance of IC-6 alloy was improved markedlyby the aluminizing coating. The protective oxide film of A12O3 prohibited the formation of molybdenumoxide. During the cyclic oxidation test, the aluminized IC-6 alloy showed improved oxidation resistancebecause of the absence of the polymorphic change of NiMoO4 phase. The dissociation of β-NiAl phase inthe aluminizing coating has not been observed after 300 hours under isothermal oxidation or 100 hoursunder cyclic oxidation in air at 1000℃. It can be concluded that the coating possesses good enoughprotective properties.

Key words： IC-6 alloy Aluminizing coating Mo_3Al phase

收稿日期: 1995-04-25

基金资助:国家８６３计划资助

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	叶长江
	李铁藩
	张亚明
	毛晓禹
44.8K

引用本文:

叶长江;李铁藩;张亚明;毛晓禹. 渗铝涂层对Ni_3Al-Mo基合金高温氧化的防护作用及机理[J]. 中国腐蚀与防护学报, 1995, 15(2): 87-92.
. INVESTIGATION ON ALUMINIZED COATING ON DS Ni_3Al-Mo BASE ALLOY. J Chin Soc Corr Pro, 1995, 15(2): 87-92.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y1995/V15/I2/87

1仲增墉．金属间化合物,北京:机械工业出版社,1992,p12韩雅芳,李孙花．金属间化合物,北京:机械工业出版社,1992,p703KubaschewskiO,HopkinsBE．OxidationofMetalsandAlloys,London:Butterworths,1962,p2454GuardRW,SmithEA．J．Inst．Metals,1959-1960,88:2835叶长江,李铁藩,沈嘉年．金属学报,1994,30(1):A44

[1]	张亚明; 李美栓 . 16Mn钢渗铝涂层在海水淬冷时的循环氧化行为[J]. 中国腐蚀与防护学报, 2002, 22(1): 44-47 .
[2]	袁福河;李铁藩;陈江. 表面取向对IC-6合金高温氧化的影响[J]. 中国腐蚀与防护学报, 1998, 18(4): 276-282.

Viewed

Full text

Abstract

Cited

Shared

Discussed