壁垒型铝阳极氧化膜的成份及电解质离子在膜中的漂移

中国腐蚀与防护学报

1987, Vol. 7

Issue (3): 161-170

研究报告

本期目录 | 过刊浏览

壁垒型铝阳极氧化膜的成份及电解质离子在膜中的漂移

徐源;ThompsonG.E.;WoodG.C.;BethuneB.B.

北京钢铁学院;英国曼彻斯特大学理工学院腐腐与保护中心;英国曼彻斯特大学理工学院腐腐与保护中心;英国曼彻斯特大学理工学院腐腐与保护中心

COMPOSITIONS OF BARRIER ANODIC FILMS ON ALUMINIUM AND THE MIGRATION OF ELECTROLYTE IONS WITHIN THE FILM

XU Yuan (Beijing University of Iron and Steel Technology) Thompson G. E.; Wood G. C.; Bethune B. B. (Corrosion and Protection Center; UMIST)

全文: PDF(1526 KB)

摘要: 讨论了俄歇能谱仪分析壁垒型铝阳极氧化膜成份的一些技术问题。配合氩离子溅射深度成份分析、离子注入标记氙原子、膜剖面超薄切片的透射电子显微镜观察,证实了壁垒型阳极氧化膜一般由内、外两层组成。外层是向膜外迁移的铝离子在膜与电解质溶液的界面上形成的;内层则是向膜内迁移的含氧离子在膜与基体界面上形成的。电解质溶液的离子会结合在膜中,并在电场影响下发生漂移。测出了存选定的实验条件下,膜中电解质离子的平均漂移速度。

Abstract：Some technical problems concerning the analysis of qarrier anodic films on aluminium by AES were discussed. By ion implantation of Xe marker, composition profiling along with direct observation of ultramicrotomed film sections, it has been proved that the barrier film is usually composed of two layers. The outer layer is formed by outwardly migrating aluminium ions at the film/solution interface. The inner layer, on the other hand, is formed by inwardly migrating oxygen-containing ions at the film/substrate interface. Ions characterizing the electrolyte may be incorporated into the film and migrate under the high electric field within the film. The average migration rate under the experimental conditions was measured.

收稿日期: 1987-06-25

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	徐源
	ThompsonG.E.
	WoodG.C.
	BethuneB.B.
44.8K

引用本文:

徐源;ThompsonG.E.;WoodG.C.;BethuneB.B.. 壁垒型铝阳极氧化膜的成份及电解质离子在膜中的漂移[J]. 中国腐蚀与防护学报, 1987, 7(3): 161-170.
. COMPOSITIONS OF BARRIER ANODIC FILMS ON ALUMINIUM AND THE MIGRATION OF ELECTROLYTE IONS WITHIN THE FILM. J Chin Soc Corr Pro, 1987, 7(3): 161-170.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y1987/V7/I3/161

[1] Randall, J. J.; Bernard, W. J., Electrochimo Acta, 20, 653(1975)
[2] ABD Rabbo, M. F.; Richardson, J. A.; Wood, G. C., Corro Sci., 16． 689(1976)
[3] Davies, J. A., Domeij, B.; Pringle, J. P. S.; Brown, F., J, Electrochem. Soc., 112, 575(1965)
[4] Davies, J. A.; Domeij, B., J. Electrochem. Soc., 120, 849(1963)
[5] Pringle, J. P. S., J. Electrochem. Soc., 119, 482(1972)
[6] Brown, F.; Mackintosh, W. D., J. Electroehem. Soc. 120, 1096(1973)
[7] Shimizu, K.; Thompson, G. E.; Wood, G. C.; Xu, Y.(徐源) Thin Solid Films, 88, 255(1982)
[8] Davies, L. E.; Maedonald, N. C.; Palm Borg, P. W.; Riaeh, G. E,; Weber, R. E. 'Handbook of Auger Spectroscopy' 2nd Ed.. Physical Electronics Inc.. U. S. A.(1976)
[9] Xu, Y.(徐源); Thompson, G. E.; Wood, G. C., 未发表工作
[10] Skeldon, P.; Shimizu, K.; Thompson, G. E.; Wood, G. C., Surface and Interface Analysis, 5, 252(1983) .
[11] Xu, Y.(徐源); Thompson, G. E.; Wood, G. C., 等发表
[12] Xu, Y.(徐源); Thompson, G. E.; Wood, G. C. J. Electrochem. Soc., 130, 2395(1983)
[13] Xu, Y.(徐源), Ph. D. Thesis, University of Manchester(1983)
[14] Skeldon, P.; Thompson, D. E.; Wood, G. C., 未发表工作
[15] Thompson, D. E.; Wood, D. C. 'Treatise in Material Slience and Technology, 23,. Edo Scully, J. C., 205(1983)
[16] Furneaux, R. C.; Thompson, G. E.; Wood, G. C. Corr. Sci., 18, 853(1978)
[17] 如Tajima, S., 'Advances in corrosion Science and Technology, 'Ed. Fontana M. G; Staehle, R. W., 1, 229(1970)

No related articles found!

Viewed

Full text

Abstract

Cited

Shared

Discussed