铝上阳极氧化膜在铬酸盐/重铬酸盐溶液中的溶解

中国腐蚀与防护学报

1982, Vol. 2

Issue (4): 27-36

研究报告

本期目录 | 过刊浏览

铝上阳极氧化膜在铬酸盐/重铬酸盐溶液中的溶解

徐乃欣;G.E.Thompson;J.L.Diwson;G.C.Wood

中国科学院上海冶金研究所;英国曼彻斯特大学理工学院腐蚀与保护中心;英国曼彻斯特大学理工学院腐蚀与保护中心;英国曼彻斯特大学理工学院腐蚀与保护中心

DISSOLUTION OF ANODIC FILMS ON ALUMINIUM IN CHROMATE/DICHROMATE SOLUTIONS

Xu Naixin (Shanahai Institute of Metallurgy.Academia Sinica)G.E.Thompson J.L.Dawson G.C.Wood (Corrosion and Protection Centre;UMIST;Manchester;U.K.)

全文: PDF(2012 KB)

摘要: 铝上的阻挡型阳极氧化膜浸泡在不同 pH 的铬酸盐/重铬酸盐溶液中时,膜的电容会不断增大,通常都把这一现象归因于阳极氧化膜的单纯的均匀减薄。然而,本研究表明,在经过这样浸泡的膜的截面超薄切片的透射电镜照片上,膜厚度的减小比由电容数据算出的结果小得多。由这两种方法获得的膜厚数据的明显差异,用膜的简单溶解是无法解释的。它很可能跟铬酸根离子在阳极氧化膜中较复杂的渗透过程有关,渗透了的膜到最终才变得松散而溶解。这一结论得到了俄歇电子能谱分析的佐证,因为在浸泡过的膜的外层发现有铬的存在。

Abstract：Natural immersion of barrier-type anodic films on aluminium in chromate /dichromate solutions of varying pH leads to a progressive increase in the film capacitance which is normally attributed to simple uniform thinning of the anodie films.However,transmission electron microscopy of ultramicro- tomed sections of the immersed films shows an overall film thickness decrease which is much less than anticipated from the measured capacitance data. This significant discrepancy between thickness data is associated with a more complex penetration of chromate species within the anodic film,with the outer layer eventually becoming disaggregated and dissolved.This conclusion is supported by Auger electron spectroscopy data,which show a chromium uptake in the outer layers of the immersed films.

收稿日期: 1982-08-25

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	徐乃欣
	G.E.Thompson
	J.L.Diwson
	G.C.Wood
44.8K

引用本文:

徐乃欣;G.E.Thompson;J.L.Diwson;G.C.Wood. 铝上阳极氧化膜在铬酸盐/重铬酸盐溶液中的溶解[J]. 中国腐蚀与防护学报, 1982, 2(4): 27-36.
. DISSOLUTION OF ANODIC FILMS ON ALUMINIUM IN CHROMATE/DICHROMATE SOLUTIONS. J Chin Soc Corr Pro, 1982, 2(4): 27-36.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y1982/V2/I4/27

[1] M.A.Heine and M.J.Pryor.J.Electrochem.Soc.,110,1205(1963)
[2] A.J.Brock and G.C.Wood,Electrochim.Acta,12,395(1967)
[3] M.F.Abd Pabbo,J.A.,Richardson,G.C.Wood and C.K.Jackson,Corrosion Science,16,677(1976)
[4] M.Kondelkova and H.Berthou,J.Electrochem.Soc.,124,1165(1977)
[5] S.Matsuzawa,N.Baba and S.Tajima,Proc Int.Cong.Metall.Corros.,p590,NACE,Houston(1972)
[6] J.A.Richardson and G.C.Wood,J.Electrochem.Soc.,120,193(1973)
[7] 徐乃欣,J.L.Dawson,G.E.Thompson and G.C.Wood,待发表结果。
[8] R.C.Furneaux,G.E.Thompson and G.C.Wood,Corros.Sci.,18,853(1978)
[9] J.J.McMullen and M.J.Pryor,Proc.First Int.Cong.Metall.Corrosion,P52,Butterworths,London(1962)
[10] D.J.O'Connor,D.G.Johansen and A.S.Buchanan,Trans.Faraday Soc.,52,229(1956)
[11] T.A.Libsch and O.F.Devereux,J.Electrochem.Soc.,123,864(1976)
[12] M.J.Pryor,Z.Elektrochem.,62,782(1958)
[13] G.C.Pimentel and R.D.Spratley,“Understanding Chemistry”P838,HoldenDay Inc.(1971)
[14] C.H.Solum,“Fundamentals of General Chemistry”,P636,2nd ed.,Prentice Hall Inc.(1965)

No related articles found!

Viewed

Full text

Abstract

Cited

Shared

Discussed