用开尔文探针研究Al-Mg-Si合金在MgCl<sub>2</sub>液滴下的腐蚀行为

中国腐蚀与防护学报

2011, Vol. 31

Issue (6): 467-472

研究报告

本期目录 | 过刊浏览

用开尔文探针研究Al-Mg-Si合金在MgCl₂液滴下的腐蚀行为

蔡超1,杨建锋1,李劲风2,曾锋利2,谭星2

1. 西安交通大学金属材料强度国家重点实验室西安 710049
2. 中南大学材料科学与工程学院长沙 410083

CORROSION OF AN Al-Mg-Si ALLOY UNDER MgCl₂ SOLUTION DROPS THROUGH KELVIN PROBE

CAI Chao¹, YANG Jianfeng¹, LI Jinfeng², ZENG Fengli², TAN Xing²

1. State Key Laboratory for Mechanical Behavior of Materials, Xi'an Jiaotong University, Xi'an 710049
2. School of Materials Science and Engineering, Central South University, Changsha 410083

全文: PDF(1409 KB)

摘要: 采用开尔文探针研究了相对湿度（RH）为75% 和33%时，Al-0.63 Mg-0.28 Si合金在原始浓度0.05 ~0.3 mol/L、体积6μL的MgCl₂液滴作用下的腐蚀行为。由于液滴水分蒸发，在合金表面形成直径约2.9~3.2 mm的MgCl₂薄液膜。当开路电位基线在基本维持稳定（-0.3~-0.5 V_vs\ SCE）的基础上重复出现电位突降而后立即回复的电位噪声时，对应于亚稳孔蚀的不断形成与钝化，合金表面生成直径小于3 μm的亚稳孔蚀。当开路电位缓慢下降至-0.7~ -0.8 V 左右并维持稳定时，对应于合金表面丝状腐蚀的形成与生长。在RH=33%气氛中，合金表面只发生亚稳孔蚀。在RH=75%气氛中，当初始浓度0.3 mol/L和0.2 mol/L时，24 h内合金主要发生亚稳孔蚀；当浓度下降至0.1 mol/L时，合金表面发生稳定腐蚀（丝状腐蚀），且丝状腐蚀发生在液滴边缘并向外扩展；当浓度进一步下降至0.05 mol/L 时，发生稳定腐蚀的几率下降，24 h内主要发生亚稳孔蚀。气氛湿度降低，单位时间内亚稳孔蚀数目降低；而相同气氛湿度条件下，随原始MgCl₂液滴浓度降低，单位时间内亚稳孔蚀数目增加。

关键词 ： Al-Mg-Si合金, 开尔文探针, MgCl₂液滴

Abstract：The corrosion behavior of Al-0.63Mg-0.28Si alloy under MgCl₂ solution drops with initial concentration of 0.05 mol/L~0.3 mol/L and volume of 6 μL in the environment of relative humidity (RH) 75% and RH 33% were studied by using Kelvin Probe. In these two environments, because the water in the drop is evaporated, a thin MgCl₂ solution layer with a diameter of about 2.9~3.2 μm forms on the alloy surface. As the open circuit potential (OCP) baseline keeps stable at -0.3~-0.5 V_vs \ SHE, there exists potential noise that the OCP repeatedly exhibits a sudden decrease and then immediate recovery, which is associated with initiation and re-passivation of metastable pits with diameter less than 3 μm. When the OCP baseline decreases slowly to -0.7~0.8 V and keeps stable low, stable filiform-like corrosion occurs and develops. In the environment of RH 33%, only metastable pitting corrosion occurs within 24 h. In the environment of RH 75%, as the initial MgCl₂concentration is 0.3 mol/L and 0.2 mol/L, the main corrosion form is metastable pitting corrosion. As the initial concentration is reduced to 0.1 mol/L, stable filiform-like corrosion always occurs on the drop edge and grows outward. As the initial concentration is further decreased to 0.05 mol/L, the likelihood of stable corrosion is lowered, and the main corrosion form is metastable pitting corrosion within 24 h. The number of metastable pits every unit time is increased with RH of the environment. Meanwhile, in environment of the same RH, it is increased with the decrease in initial concentration.

Key words： Al-Mg-Si alloy Kelvin probe (KP) MgCl₂ solution drop

收稿日期: 2010-09-10

ZTFLH:

TG172

基金资助:

国家自然科学基金项目(50771092、21073162)资助

通讯作者: 李劲风 E-mail: lijinfeng@csu.edu.cn

Corresponding author: LI Jinfeng E-mail: lijinfeng@csu.edu.cn

作者简介: 蔡超，男，1978年生，博士，副教授，研究方向为铝合金材料及其腐蚀与防护

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	李劲风
44.8K

引用本文:

蔡超,杨建锋,李劲风,曾锋利,谭星. 用开尔文探针研究Al-Mg-Si合金在MgCl₂液滴下的腐蚀行为[J]. 中国腐蚀与防护学报, 2011, 31(6): 467-472.
LI Jin-Feng. CORROSION OF AN Al-Mg-Si ALLOY UNDER MgCl₂ SOLUTION DROPS THROUGH KELVIN PROBE. J Chin Soc Corr Pro, 2011, 31(6): 467-472.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y2011/V31/I6/467

[1] El-Mahdy G A, Nishikata A, Tsuru T. AC impedance study on corrosion of 55%Al-Zn alloy-coated steel under thin electrolyte layers[J]. Corros. Sci., 2000, 42: 1509-1521

[2] Tang X, Wang J, Li Y K. Corrosion behavior of stainless steel under NaCl electrolyte thin film[J]. Corros. Sci. Prot.Technol., 2009, 21(3): 227-229

    (唐晓, 王佳, 李亚坤等.NaCl薄液膜下不锈钢腐蚀行为研究[J]. 腐蚀科学与防护技术, 2009, 21(3):227-229)

[3] Nishikata A, Ichihara Y, Tsuru T. Influence of electrolyte layer thickness and pH on the initial stage of the atmospheric corrosion of iron[J]. J. Electrochem. Soc., 1997, 144: 1244-1252

[4] Cheng Y L, Zhang Z, Cao F H, et al. A study of the corrosion of aluminum alloy 2024-T3 under thin electrolyte layers[J]. Corros. Sci. 2004, 46: 1649-1667

[5] Shi Y Y, Zhang Z, Cheng Y L, et al. Corrosion behaviour of LY12 alloy under thin electrolyte films[J]. Bull. Electrochem.,2004, 20: 261-266

[6] Li Q X, Wang Z Y, Han W, et al. Corrosion behavior of weathering steel in a wet/dry environment containing MgCl₂[J]. J. Chin. Soc. Corros. Prot., 2006, 26(3): 236-140

    (李巧霞,王振尧, 韩薇等. 耐候钢在含MgCl₂介质的干湿环境下的腐蚀行为[J].中国腐蚀与防护学报, 2006, 26(3): 236-140)

[7] Yaday A P, Nishikata A, Tsuru T. Electrochemical impedance study on galvanized steel corrosion under cyclic wet-dry conditions-influence of time of wetness[J]. Corros. Sci., 2004, 46:169-181

[8] Shi Y Y, Zhang Z, Su J X, et al. Electrochemical noise study on 2024-T3 Aluminum alloy corrosion in simulated acid rain under cyclic wet-dry condition[J]. Electrochim. Acta, 2006, 51:4977-4986

[9] Dubuisson E, Lavie P, Dalard F, et al. Corrosion of galvanised steel under an electrolytic drop[J]. Corros. Sci., 2007,49: 910-919

[10] Dubuisson E, Lavie P, Dalard F, et al. Study of the atmospheric corrosion of galvanised steel in a micrometric electrolytic droplet[J]. Electrochem. Commun., 2006, 8: 911-915

[11] Zhang J Q, Zhang Z, Wang J. M, et al. Analysis and application of electrochemical noise technology II. Application of electrochemical noise[J]. J. Chin. Soc. Corros. Prot., 2002, 22(4):241-247

     (张鉴清, 张昭, 王建明等.电化学噪声的分析与应用Ⅱ.电化学噪声的应用[J]. 中国腐蚀与防护学报,2002, 22(4):241-247)

[12] Stratmann M, Streckel H. On the atmospheric corrosion of metals which are covered with thin electrolyte layers. 1.Verification of the experimental-technique[J]. Corros. Sci., 1990,30: 681-696

[13] Stratmann M, Streckel H. On the atmospheric corrosion of metals which are covered with thin electrolyte layers. 2.Experimental results[J]. Corros. Sci., 1990, 30: 697-714

[14] Maier B, Frankel G S. Pitting corrosion of bare and silica-coated stainless steel 304 under thin electrolyte layers[J].Electrochem. Soc., 2010, 157: C302-C312

[15] Zhou H R, Li X G, Ma J, et al. Dependence of the corrosion behavior of aluminum alloy 7075 on the thin electrolyte layers[J]. Mate. Sci., Eng. 2009, B162: 1-8

[1]	王力伟, 李晓刚, 杜翠薇, 曾笑笑. 微区电化学测量技术进展及在腐蚀领域的应用[J]. 中国腐蚀与防护学报, 2010, 30(6): 498-503.
[2]	李朝兴;李劲风;BIRBILIS Nick;贾志强;郑子樵. Mg₂Si及Si粒子在Al-Mg-Si合金晶间腐蚀中协同作用机理的多电极偶合研究[J]. 中国腐蚀与防护学报, 2010, 30(2): 107-113.

Viewed

Full text

Abstract

Cited

Shared

Discussed