Please wait a minute...
中国腐蚀与防护学报  1988, Vol. 8 Issue (1): 15-20    
  研究报告 本期目录 | 过刊浏览 |
用微机实施恒电位阴极保护
杨金伟;徐乃欣;张承典
中国科学院上海冶金研究所;中国科学院上海冶金研究所;中国科学院上海冶金研究所
A MICROCOMPUTER-BASED CATHODIC PROTECTION SYSTEM
Yang Jinwei Xu Naixin Zhang Chengdian (Shanghai Institute of Mefallurgy Academia Sinica)
全文: PDF(535 KB)  
摘要: 本工作中研制了一种用微机直接控制的恒电位阴极保护电源.其基本原理完全不同于现有恒电位仪的反馈控制。它定时对阴极电位采样,根据与给定值的偏差,通过可变比例控制算法,调整可控硅电源的输出电压,并保持这一输出电压直至下一次采样。在这种控制方式下,除电位采样和控制算法以外的大部份时间内,微机处于“闲置”工作状态,并且参比电极与控制系统无关.这样的保护电源可望方便地扩展到多通道巡回控制,用单一电源对多阳极系统实施恒电位阴极保护。
Abstract:A microcomputer based system for impressed current cathodic protection was developed on the basis of the fact that under steady state condition prot- ection potemtial will not change much if voltage of d.c.supply is maintained.Its operating principle is entirely different from that of available industrial potentiostat,in which closed-loop feedback control is continuously executed. Potential control with the new system is achieved by periodic adjustments of d.c.power output.Potential received periodically from a sensing electrode is compared with a preset control value and their difference is fed into an A/D converter.Then the digital signal goes into microcomputer and a result- isng voltage proportional to potential difference is sent to thyristor circuit to correct the d.c.output voltage.Steady state condition is reached by suc- cessive adjustments.The operation of the system was demonstrated by cathodic protection of mild steel at +0.1V vs zinc reference electrode in portable water.When a sampling period of 0.7second was taken,a potential control accuracy of +10 mV was obtained.The most attractive feature of this new design is that it could be easily extended to multi-anode system.Iu this case each anode is driven by its own d.c.power module and is under computer control periodically.
收稿日期: 1988-02-25     

引用本文:

杨金伟;徐乃欣;张承典. 用微机实施恒电位阴极保护[J]. 中国腐蚀与防护学报, 1988, 8(1): 15-20.
. A MICROCOMPUTER-BASED CATHODIC PROTECTION SYSTEM. J Chin Soc Corr Pro, 1988, 8(1): 15-20.

链接本文:

https://www.jcscp.org/CN/      或      https://www.jcscp.org/CN/Y1988/V8/I1/15

[1] Britton,J.N.;Holt,R.Corrosion/86. PaPer No.73
[2] pawson.R.L;Benchetrit.G.Corrosion/86. PaPer No.76
[3] Hagcock.E.W.Corrosion/73,PaPer No.69
[4] 朱加符邓天影,金属腐蚀与防护,4,(1979)
[5] 马士德,金属腐蚀与防护,3,(1979)
No related articles found!