Please wait a minute...
中国腐蚀与防护学报  2021, Vol. 41 Issue (6): 864-870    DOI: 10.11902/1005.4537.2020.176
  研究报告 本期目录 | 过刊浏览 |
六方氮化硼改性硅烷膜耐蚀性能研究
丁玉康1, 陈国美2, 倪自丰1(), 刘雅玄1, 钱善华1, 卞达1, 赵永武1
1.江南大学机械工程学院 无锡 214122
2.无锡商业职业技术学院机电工程学院 无锡 214122
Corrosion Resistance of Silane Film Modified by Hexagonal Boron Nitride
DING Yukang1, CHEN Guomei2, NI Zifeng1(), LIU Yaxuan1, QIAN Shanhua1, BIAN Da1, ZHAO Yongwu1
1.College of Mechanical Engineering, Jiangnan University, Wuxi 214122, China
2.School of Mechanical and Electrical Engineering, Wuxi Vocational Institute of Commerce, Wuxi 214122, China
全文: PDF(10895 KB)   HTML
摘要: 

采用多巴胺对氮化硼进行非共价改性,通过SEM、红外光谱和TGA对粉末进行了表征。使用浸泡法在40Cr合金钢表面制备了掺杂改性氮化硼 (mBN) 的硅烷复合膜,运用SEM、红外光谱、润湿性测试以及动电位极化曲线研究了硅烷复合膜的耐蚀性能。结果表明,聚多巴胺成功附着在氮化硼表面,掺杂mBN的硅烷膜厚度增大至1.812 μm,mBN/BTESPT硅烷复合膜的表面接触角达到91.97°,动电位腐蚀电流密度为9.187×10-8 A/cm2,耐蚀性能相比单一硅烷膜提高了约30倍,在中性盐雾测试中表现出较好的耐蚀性。mBN通过对硅烷膜的物理填充与化学键结合,阻碍了腐蚀介质的扩散,显著增强了金属的耐蚀性能。

关键词 硅烷膜六方氮化硼改性耐蚀性    
Abstract

Powders of boron nitride were non-covalently modified with dopamine, and then composite silane coatings dopped with non-covalently modified boron nitride were prepared on 40Cr alloy steel surface via socking method. The modified powder was characterized by SEM, FTIR and TGA. The corrosion resistance of silane composite film was studied by SEM, FTIR, wettability measurement and potentiodynamic polarization curve. The results showed that the polydopamine successfully coats the boron nitride particles and adheres them onto the 40Cr steel surface, the thickness of the mBN-doped silane film increased to 1.812 μm, and the surface contact angle of the mBN/BTESPT silane composite film reached 91.97°. The corrosion current density of the composite film coated steel was 9.187×10-8 A/cm2, which implies that the corrosion resistance of the composite film was about 30 times higher than that of the bare silane film, and it showed also better corrosion resistance in the neutral salt spray test. Through the physical filling and chemical bonding of silane film, mBN hindered the diffusion of corrosion medium and significantly enhanced the corrosion resistance of metal.

Key wordssilane film    hexagonal boron nitride    modification    corrosion resistance
收稿日期: 2020-09-27     
ZTFLH:  TG174.4  
基金资助:国家自然科学基金(51675232)
通讯作者: 倪自丰     E-mail: nizf@jiangnan.edu.cn
Corresponding author: NI Zifeng     E-mail: nizf@jiangnan.edu.cn
作者简介: 丁玉康,男,1996年生,硕士生

引用本文:

丁玉康, 陈国美, 倪自丰, 刘雅玄, 钱善华, 卞达, 赵永武. 六方氮化硼改性硅烷膜耐蚀性能研究[J]. 中国腐蚀与防护学报, 2021, 41(6): 864-870.
Yukang DING, Guomei CHEN, Zifeng NI, Yaxuan LIU, Shanhua QIAN, Da BIAN, Yongwu ZHAO. Corrosion Resistance of Silane Film Modified by Hexagonal Boron Nitride. Journal of Chinese Society for Corrosion and protection, 2021, 41(6): 864-870.

链接本文:

https://www.jcscp.org/CN/10.11902/1005.4537.2020.176      或      https://www.jcscp.org/CN/Y2021/V41/I6/864

图1  BN粉末与mBN的SEM形貌
图2  BN与mBN的红外光谱图
图3  BN与mBN的热失重曲线
图4  不同试样的表面形貌图
图5  BTESPT膜与mBN/BTESPT膜的FT-IR图
图6  不同试样接触角测试结果
图7  不同处理试样的Tafel曲线
SampleEcorr / VIcorr / A·cm-2ŋp / %
Alloy steel-0.62454.064×10-5---
BTESPT-0.46152.616×10-693.56
BN/BTESPT-0.44227.832×10-798.07
mBN/BTESPT-0.44899.187×10-899.77
表1  Tafel动电位腐蚀参数
图8  不同试样在盐雾实验下的表面形貌
图9  mBN/BTESPT膜的成膜示意图
1 Gong B B, Liu G, Bai Y, et al. Effect of chromate-free phosphating treatment of 7075 aluminum alloy on properties of film [J]. Mater. Prot., 2019, 52(1): 51
1 龚兵兵, 刘刚, 白勇等. 7075铝合金无铬磷化成膜动力学过程及其性能 [J]. 材料保护, 2019, 52(1): 51
2 Zhang X H, Feng L J, Liu Z, et al. Effect of phosphating interlayer on properties of Ni-P coating on AZ63 magnesium alloy [J]. Total Corros. Control, 2018, 32(7): 66
2 张小欢, 冯拉俊, 刘政等. 磷化处理对AZ63镁合金化学镀Ni-P的影响 [J]. 全面腐蚀控制, 2018, 32(7): 66
3 Yang M Y, Liu D F. Chromate passivating of electroless Ni-P alloy coating and the corrosion resistance study [J]. Electroplat. Pollut. Control, 2016, 36(5): 24
3 杨明悦, 刘定富. 化学镀Ni-P合金镀层铬酸盐钝化及其耐蚀性的研究 [J]. 电镀与环保, 2016, 36(5): 24
4 Ilman M N. Chromate inhibition of environmentally assisted fatigue crack propagation of aluminium alloy AA 2024-T3 in 3.5%NaCl solution [J]. Int. J. Fatigue, 2014, 62: 228
5 Li H, Sun J H, Zhong Q D, et al. Effect of the bluing solution on corrosion resistance of the oxide film prepared in steel [J]. Mater. Sci. Forum, 2017, 893: 345
6 Zhu D Q, Van Ooij W J. Corrosion protection of metals by water-based silane mixtures of bis-[trimethoxysilylpropyl] amine and vinyltriacetoxysilane [J]. Prog. Org. Coat., 2004, 49: 42
7 Li J, Cao X L, Dai S Q, et al. Preparation and corrosion resistance of zirconium-titanium/silane composite film on magnesium alloy surface [J]. Surf. Technol., 2018, 47(10): 216
7 李洁, 曹献龙, 戴崧乾等. 镁合金表面锆钛硅烷复合膜层的制备及耐蚀性研究 [J]. 表面技术, 2018, 47(10): 216
8 Xian X, Nai C, Li L, et al. The formation process of Zr-doped silane film on carbon steel during immersing in Zr(NO3)4/silane mixed solutions [J]. Anti-Corros. Methods Mater., 2017, 64: 1
9 Zhang M M, Li W C, Zhang S L. Corrosion resistance of silane films modified with yttrium oxide nanoparticles on AA6061-T6 Al alloy surface [J]. Corros. Prot., 2014, 35: 1122
9 张明明, 李文超, 张圣麟. AA6061-T6铝合金表面纳米Y2O3改性硅烷膜的耐蚀性 [J]. 腐蚀与防护, 2014, 35: 1122
10 Zhu H Z, Yue L F, Zhuang C, et al. Fabrication and characterization of self-assembled graphene oxide/silane coatings for corrosion resistance [J]. Surf. Coat. Technol., 2016, 304: 76
11 Mahdavian M, Ramezanzadeh B, Akbarian M, et al. Enhancement of silane coating protective performance by using a polydimethylsiloxane additive [J]. J. Ind. Eng. Chem., 2017, 55: 244
12 Wu H J, Yang F Y, Zhou L H, et al. Electrochemical corrosion behavior of cerium salt doped silane composite films on AZ91D magnesium alloy [J]. Surf. Technol., 2017, 46(9): 209
12 吴海江, 杨飞英, 邹利华等. 镁合金表面铈盐掺杂硅烷膜的腐蚀电化学行为 [J]. 表面技术, 2017, 46(9): 209
13 Falin A, Cai Q R, Santos E J G, et al. Mechanical properties of atomically thin boron nitride and the role of interlayer interactions [J]. Nat. Commun., 2017, 8: 15815
14 Brusciotti F, Snihirova D V, Xue H B, et al. Hybrid epoxy-silane coatings for improved corrosion protection of Mg alloy [J]. Corros. Sci., 2013, 67: 82
15 Coan T, Barroso G S, Motz G, et al. Preparation of PMMA/hBN composite coatings for metal surface protection [J]. Mater. Res., 2013, 16: 1366
16 Husain E, Narayanan T N, Taha-Tijerina J J, et al. Marine corrosion protective coatings of hexagonal boron nitride thin films on stainless steel [J]. ACS Appl. Mater. Int., 2013, 5: 4129
17 Yi M, Shen Z G, Zhao X H, et al. Boron nitride nanosheets as oxygen-atom corrosion protective coatings [J]. Appl. Phys. Lett., 2014, 104: 143101
18 Li L H, Xing T, Chen Y, et al. Boron nitride nanosheets for metal protection [J]. Adv. Mater. Int., 2014, 1: 1300132
19 Zhuang C, Zhu H Z, Zhang Z Y. Preparation and protective effects of hexagonal boron nitride coatings [J]. Shandong Chem. Ind., 2016, 45(16): 19
19 庄忱, 朱弘政, 张振岳. 六方氮化硼涂层的制备及防护性能研究 [J]. 山东化工, 2016, 45(16): 19
20 Shen L T, Zhao Y D, Wang Y, et al. A long-term corrosion barrier with an insulating boron nitride monolayer [J]. J. Mater. Chem., 2016, 4A: 5044
21 Ren S M, Cui M J, Zhao H C, et al. Corrosion behavior of epoxy coating containing poly-dopamine modified hexagonal boron nitride [J]. China Surf. Eng., 2017, 30(2): 98
21 任思明, 崔明君, 赵海超等. 聚多巴胺修饰六方氮化硼及其环氧复合涂层的腐蚀行为 [J]. 中国表面工程, 2017, 30(2): 98
22 Kim K, Kim J. Vertical filler alignment of boron nitride/epoxy composite for thermal conductivity enhancement via external magnetic field [J]. Int. J. Therm. Sci., 2016, 100: 29
23 Zhang Y, Huang F, Ma J R, et al. Effects of Hydroxyl treatment on atomic resistance property of hexagonal boron nitride film [J]. J. Mater. Eng., 2018, 46(7): 61
23 张宇, 黄峰, 马金瑞等. 羟基化处理对氮化硼膜耐原子氧性能的影响 [J]. 材料工程, 2018, 46(7): 61
24 Jin H, Li Y F, Li X D, et al. Functionalization of hexagonal boron nitride in large scale by a low-temperature oxidation route [J]. Mater. Lett., 2016, 175: 244
25 Ma P, Spencer J T. Non-covalent stabilization and functionalization of boron nitride nanosheets (BNNSs) by organic polymers: Formation of complex BNNSs-containing structures [J]. J. Mater. Sci., 2015, 50: 313
26 Zeng X L, Ye L, Yu S H, et al. Artificial nacre-like papers based on noncovalent functionalized boron nitride nanosheets with excellent mechanical and thermally conductive properties [J]. Nanoscale, 2015, 7: 6774
27 Shen H, Guo J, Wang H, et al. Bioinspired modification of h-BN for high thermal conductive composite films with aligned structure [J]. ACS Appl. Mater. Int., 2015, 7: 5701
28 Chen L, Li K, Li B, et al. Enhanced thermal conductivity of benzoxazine nanocomposites based on non-covalent functionalized hexagonal boron nitride [J]. Compos. Sci. Technol., 2019, 182: 107741
29 Yang X, Ni Z F, Zhao Y W, et al. Hydrolysis process optimization and evaluation of corrosion resistance of graphene oxide modified silane film [J]. Mater. Prot., 2018, 51(11): 61
29 杨鑫, 倪自丰, 赵永武等. 氧化石墨烯改性硅烷膜水解工艺优选及膜层的耐蚀性 [J]. 材料保护, 2018, 51(11): 61
30 Huang Y, Sarkar D K, Gallant D, et al. Corrosion resistance properties of superhydrophobic copper surfaces fabricated by one-step electrochemical modification process [J]. Appl. Surf. Sci., 2013, 282: 689
31 Cai W, Guo W W, Pan Y, et al. Polydopamine-bridged synthesis of ternary h-BN@PDA@SnO2 as nanoenhancers for flame retardant and smoke suppression of epoxy composites [J]. Composites, 2018, 111A: 94
32 Balan P, Shelton M J, Ching D O L, et al. Modified silane films for corrosion protection of mild steel [J]. Proced. Mater. Sci., 2014, 6: 244
33 Van Ooij W J, translated by Fu D S, Fu Y. Application of silane coupling agents on metals [J]. Sur. Technol., 1999, 28(4): 37
33 威姆 W J著, 傅德生, 傅原译. 硅烷偶联剂在金属上的应用 [J]. 表面技术, 1999, 28(4): 37
34 Palanivel V, Zhu D Q, Van Ooij W J. Nanoparticle-filled silane films as chromate replacements for aluminum alloys [J]. Prog. Org. Coat., 2003, 47: 384
[1] 周殿买, 姜磊, 王美婷, 梁洪嘉, 肖云龙, 郑黎, 于宝义. Ce(NO3)2浓度及硅酸盐封孔处理对高铁枕梁用Mg-Zn-Y-Ca合金表面钙系磷化膜的影响[J]. 中国腐蚀与防护学报, 2021, 41(6): 849-856.
[2] 刘星, 冉斗, 孟惠民, 李全德, 巩秀芳, 隆彬. 表面状态对TC4钛合金的耐蚀性影响[J]. 中国腐蚀与防护学报, 2021, 41(6): 828-836.
[3] 房豪杰, 曲华, 杨黎晖, 曾庆亚, 王丽丹, 袁宁, 侯保荣, 曹立新, 袁迅道. 9C系列粉末冶金高耐蚀铝合金腐蚀行为研究[J]. 中国腐蚀与防护学报, 2021, 41(6): 775-785.
[4] 张陈扬, 刘慧丛, 韩东晓, 朱立群, 李卫平. 微米级SiC/Ni-Co-P复合镀层的制备及影响因素[J]. 中国腐蚀与防护学报, 2021, 41(5): 579-584.
[5] 郎丰军, 黄峰, 徐进桥, 李利巍, 岳江波, 刘静. Mg处理X70级抗酸性海底管线钢 (X70MOS) 成分设计及耐蚀性能研究[J]. 中国腐蚀与防护学报, 2021, 41(5): 617-624.
[6] 吴林涛, 周泽华, 张欣, 杨光恒, 张凯城, 王光宇. 等离子喷涂FeCrMoCBY铁基非晶涂层耐蚀性研究[J]. 中国腐蚀与防护学报, 2021, 41(5): 717-720.
[7] 刘宏宇, 张喜庆, 滕莹雪, 李胜利. 含铜低碳钢在海洋环境下的耐蚀和防污性能的研究[J]. 中国腐蚀与防护学报, 2021, 41(5): 679-685.
[8] 杨光恒, 周泽华, 张欣, 吴林涛, 梅婉. 磁场作用下不同Mg含量Al-Mg合金腐蚀行为研究[J]. 中国腐蚀与防护学报, 2021, 41(5): 633-638.
[9] 张浩然, 吴鸿燕, 王善林, 左瑶, 陈玉华, 尹立孟. 含硫化物夹杂的铁基非晶合金点蚀规律[J]. 中国腐蚀与防护学报, 2021, 41(4): 477-486.
[10] 王东亮, 丁华平, 马云飞, 龚攀, 王新云. 非晶合金耐蚀性研究进展[J]. 中国腐蚀与防护学报, 2021, 41(3): 277-288.
[11] 韩月桐, 张鹏超, 史杰夫, 李婷, 孙俊才. 质子交换膜燃料电池中TA1双极板的表面改性研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 125-130.
[12] 黄鹏, 高荣杰, 刘文斌, 尹续保. 盐溶液刻蚀-氟化处理制备X65管线钢镀镍超双疏表面及其耐蚀性研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 96-100.
[13] 包任, 周根树, 李宏伟. 恒电位脉冲电沉积高锡青铜耐蚀镀层工艺研究[J]. 中国腐蚀与防护学报, 2020, 40(6): 585-591.
[14] 刘海霞, 黄峰, 袁玮, 胡骞, 刘静. 690 MPa级高强贝氏体钢在模拟乡村大气中的腐蚀行为[J]. 中国腐蚀与防护学报, 2020, 40(5): 416-424.
[15] 李聪玮, 杜双明, 曾志琳, 刘二勇, 王飞虎, 马付良. 电流密度对Ni-Co-B镀层微观结构及磨蚀性能的影响[J]. 中国腐蚀与防护学报, 2020, 40(5): 439-447.