Please wait a minute...
中国腐蚀与防护学报
  本期目录 | 过刊浏览 |
桥梁钢Q345q在三种模拟大气环境中的腐蚀行为研究
郭铁明1,张延文1,秦俊山2,宋志涛1,董建军2,杨新龙3
1. 兰州理工大学
2. 酒泉集团宏兴钢铁股份有限公司
3. 酒泉宏兴集团钢铁有限公司
A Study on Corrosion Behavior of Q345q Bridge Steel in Three Simulated Atmosphere
全文: PDF(3247 KB)  
摘要: 摘要:本文选择三种模拟西北地区大气环境的腐蚀介质(除冰盐介质、工业大气介质及除冰盐+工业大气介质),采用干湿交替加速腐蚀实验方法研究了桥梁钢Q345q的腐蚀行为,通过失重法探讨了桥梁钢Q345q在三种不同腐蚀环境下的腐蚀动力学曲线,并采用XRD、SEM和电化学工作站等分析了桥梁钢Q345q腐蚀不同时间的锈层物相、形貌及结构和锈层的电化学特性。结果表明:在480h内虽然在除冰盐介质中腐蚀速率小,但产物含有β-FeOOH和氯化物等不稳定可溶性的腐蚀产物,导致锈层疏松,锈层腐蚀电流增大,锈层不具保护性;在亚硫酸氢钠介质中的腐蚀速率较高,但随着腐蚀时间的延长锈层致密性增加,腐蚀速率下降较快,锈层阳极稳态腐蚀电流减小,锈层具有保护性。而在混和介质中腐蚀行为为耦合效应,由于氯化物等腐蚀产物使得锈层致密性下降,但锈层具有一定的保护性。
关键词 关键词:桥梁钢Q345q除冰盐亚硫酸氢钠介质混合介质腐蚀行为    
Abstract:ABSTRACT:In this paper, three kinds of corrosive medium for simulating the atmospheric environment in Northwest China (deicing medium, industrial atmospheric medium and deicing salt + industrial atmosphere medium) are selected. Corrosion behavior of Q345q bridge steel was studied by dry-wet alternating accelerated corrosion test method, the corrosion kinetics curves of Q345q bridge steel under three different corrosive environments were investigated by weight loss method. The phase, morphology and structure of rust layer and the electrochemical properties of rust layer of Q345q bridge steel corroded for different time were analyzed by XRD, SEM and electrochemical workstation. The results show that although the corrosion rate is small in the deicing salt medium within 480h, the product contains unstable soluble corrosion products such as β-FeOOH and chloride, which results in loose rust layer, the corrosion current of the rust layer increases and the rust layer is not protected. The corrosion rate in the Sodium Bisulfite medium is higher, but with the increase of corrosion time, the corrosion rate decreases rapidly, the anode corrosion current of the rust layer decreases and the rust layer is protective. In the mixed medium, the corrosion behavior is a coupling effect. Due to corrosion products such as chlorides, the compactness of the rust layer decreases, but the rust layer has a certain degree of protection.
Key wordsKEY WORDS bridge steelQ345q    deicing salt    the Sodium Bisulfite medium    mixed medium    corrosion behavior
收稿日期: 2018-09-10     
ZTFLH:  TG172.3  
基金资助:国家自然基金资助项目;广东省“扬帆计划”引进创新创业团队专项资助
通讯作者: 郭铁明   

引用本文:

郭铁明 张延文 秦俊山 宋志涛 董建军 杨新龙. 桥梁钢Q345q在三种模拟大气环境中的腐蚀行为研究[J]. 中国腐蚀与防护学报, .

链接本文:

https://www.jcscp.org/CN/Y0/V/I/0

[1] 黄涛, 许春香, 杨丽景, 李福霞, 贾庆功, 宽军, 张正卫, 武晓峰, 王中琪. Zr含量对Mg-3Zn-1Y合金显微组织和腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2021, 41(2): 219-225.
[2] 李琳, 陈义庆, 高鹏, 艾芳芳, 钟彬, 伞宏宇, 杨颖. 除冰盐环境下桥梁钢的耐腐蚀性能研究[J]. 中国腐蚀与防护学报, 2020, 40(5): 448-454.
[3] 张欣, 杨光恒, 王泽华, 曹静, 邵佳, 周泽华. 冷拉拔变形过程中含稀土铝镁合金腐蚀行为研究[J]. 中国腐蚀与防护学报, 2020, 40(5): 432-438.
[4] 胡露露, 赵旭阳, 刘盼, 吴芳芳, 张鉴清, 冷文华, 曹发和. 交流电场与液膜厚度对A6082-T6铝合金腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2020, 40(4): 342-350.
[5] 王新华, 杨永, 陈迎春, 位凯玲. 交流电流对X100管线钢在库尔勒土壤模拟液中腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2020, 40(3): 259-265.
[6] 胡玉婷, 董鹏飞, 蒋立, 肖葵, 董超芳, 吴俊升, 李晓刚. 海洋大气环境下TC4钛合金与316L不锈钢铆接件腐蚀行为研究[J]. 中国腐蚀与防护学报, 2020, 40(2): 167-174.
[7] 张尧, 郭晨, 刘妍慧, 郝美娟, 成世明, 程伟丽. 挤压态Mg-2Sn-1Al-1Zn合金在模拟体液中的电化学腐蚀行为[J]. 中国腐蚀与防护学报, 2020, 40(2): 146-150.
[8] 苏小红,胡会娥,孔小东. W颗粒/Zr41.2Ti13.8Cu12.5Ni10Be22.5基非晶复合材料在3%NaCl溶液中的腐蚀行为研究[J]. 中国腐蚀与防护学报, 2020, 40(1): 70-74.
[9] 王勤英,裴芮,西宇辰. 镍基激光熔覆层冲刷腐蚀行为研究[J]. 中国腐蚀与防护学报, 2019, 39(5): 458-462.
[10] 郭铁明,张延文,秦俊山,宋志涛,董建军,杨新龙,南雪丽. 桥梁钢Q345q在3种模拟大气环境中的腐蚀行为研究[J]. 中国腐蚀与防护学报, 2019, 39(4): 319-330.
[11] 黄博博,刘平,刘新宽,梅品修,陈小红. 新型HSn70-1铜网衣两年期海水腐蚀行为研究[J]. 中国腐蚀与防护学报, 2018, 38(6): 594-600.
[12] 曹海娇, 魏英华, 赵洪涛, 吕晨曦, 毛耀宗, 李京. Q345钢预热时间对熔结环氧粉末涂层防护性能的影响II:涂层体系失效行为分析[J]. 中国腐蚀与防护学报, 2018, 38(3): 255-264.
[13] 张杰, 胡秀华, 郑传波, 段继周, 侯保荣. 海洋微藻环境中钙质层对Q235碳钢腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2018, 38(1): 18-25.
[14] 张子阳,王善林,章恒瑜,柯黎明. AZ31镁合金搅拌摩擦焊接头腐蚀行为[J]. 中国腐蚀与防护学报, 2017, 37(2): 117-125.
[15] 刘栓,周开河,方云辉,徐孝忠,江炯,郭小平,郑文茹,蒲吉斌,王立平. 环境因素对纯Zn在饱和Zn(OH)2溶液中腐蚀行为的影响I—Cl-浓度和pH值[J]. 中国腐蚀与防护学报, 2016, 36(6): 522-528.