Please wait a minute...
中国腐蚀与防护学报
  本期目录 | 过刊浏览 |
预应变对DP600钢氢脆敏感性的影响
柯书忠1,刘静2,黄峰2,程朝阳1,方成1
1. 武汉科技大学
2. 武汉科技大学材料与冶金学院
Effect of Pre-strain on Hydrogen Embrittlement of DP600 Steels
全文: PDF(1098 KB)  
摘要: 摘 要 利用慢应变速率拉伸试验(SSRT)及双电解池渗氢试验,结合断口形貌观察和分析,探索了预应变对DP600钢氢脆敏感性的影响规律及机理。结果表明:在本试验预应变量范围内,预应变量小于15%时,随着预应变量的增大,DP600钢试样的氢脆敏感性不断增大,当预应变量达到15%以后,其氢脆敏感性基本趋于稳定。预应变增大了钢中的位错密度,使氢的有效扩散系数降低,有效捕获氢的量增加,从而使钢试样的氢脆敏感性增大;但当预应变量进一步增加至15%以上时,位错的相互缠结减缓氢的扩散和聚集速度,从而使试样的氢脆敏感性增加趋于平缓。
关键词 关键词 DP600钢预应变慢应变速率拉伸试验渗氢技术氢脆敏感性氢扩散    
Abstract:ABSTRACT The effect of pre-strain on hydrogen embrittlement (HE) of DP600 steels was studied by employing slow strain-rate tensile (SSRT), electrochemical permeation technique and fractograph.The results indicate that the HE susceptibility of DP600 steels increases with increasing pre-strain when the level of pre-strain is below 15%,and then tends to stable when the pre-strain exceeds 15%.The pre-strain increases dislocation density and the amount of effective hydrogen in steels, but decreases the effective diffusivity (Deff) of hydrogen, so that the HE susceptibility increases.However, when the pre-strain increases to more than 15%,the HE susceptibility gradually becomes stable due to decreasing in hydrogen diffusion and accumulation caused by dislocation tangle.
Key wordsKEY WORDS DP600 steels    pre-strain    SSRT    electrochemical permeation technique    HE susceptibility    diffusion of hydrogen
收稿日期: 2017-10-11     
基金资助:国家自然科学基金资助项目
通讯作者: 刘静   

引用本文:

柯书忠 刘静 黄峰 程朝阳 方成. 预应变对DP600钢氢脆敏感性的影响[J]. 中国腐蚀与防护学报, .

链接本文:

https://www.jcscp.org/CN/Y0/V/I/0

[1] 张慧云, 郑留伟, 孟宪明, 梁伟. 电化学充氢对Cr15铁素体不锈钢和304奥氏体不锈钢氢脆敏感性的影响[J]. 中国腐蚀与防护学报, 2021, 41(2): 202-208.
[2] 柯书忠, 刘静, 黄峰, 王贞, 毕云杰. 预应变对DP600钢氢脆敏感性的影响[J]. 中国腐蚀与防护学报, 2018, 38(5): 424-430.
[3] 黄本生,江仲英,潘欢欢,袁鹏斌,刘清友. 热处理工艺对G105钻杆材料抗腐蚀性能的影响[J]. 中国腐蚀与防护学报, 2012, 32(1): 67-69.
[4] 王艳飞,巩建鸣,唐建群,蒋旺,姜莹洁. 冷拔残余应力应变对钢丝氢扩散过程的影响[J]. 中国腐蚀与防护学报, 2011, 31(3): 202-207.
[5] 林召强,马力,闫永贵. 阴极极化对高强度船体结构钢焊缝氢脆敏感性的影响[J]. 中国腐蚀与防护学报, 2011, 31(1): 46-50.
[6] 李华飞; 徐金文; 刘根凡 . 渗铝钢的抗氢损伤性能[J]. 中国腐蚀与防护学报, 2005, 25(4): 237-240 .
[7] 傅朝阳;郑家燊. 钻井液中碳钢的氢扩散和腐蚀疲劳行为[J]. 中国腐蚀与防护学报, 1997, 17(4): 263-268.
[8] 路民旭;郑修麟. 超高强度钢CF裂纹扩展的超载效应 Ⅰ.定量模型及预测[J]. 中国腐蚀与防护学报, 1994, 14(3): 184-192.