Please wait a minute...
中国腐蚀与防护学报  2014, Vol. 34 Issue (1): 53-58    DOI: 10.11902/1005.4537.2013.045
  本期目录 | 过刊浏览 |
周期干湿浸条件下P265GH钢和Q235钢的大气腐蚀行为
王振尧1(), 于全成1, 陈军君2, 王军2, 徐松2, 胡波涛2
1. 中国科学院金属研究所 金属腐蚀与防护国家重点实验室 沈阳 110016
2. 湖南电力公司科学研究院 长沙 410007
Atmospheric Corrosion Behavior of P265GH Steel and Q235 Steel under Dry/Humid/Immersion Alternative Condition
WANG Zhenyao1(), YU Quancheng1, CHEN Junjun2, WANG Jun2, XU Song2, HU Botao2
1. State Key Laboratory for Corrosion and Protection, Institute of Metal Research, Chinese Academy of Sciences, Shenyang 110016, China
2. Hunan Electric Power Corporation Research Institute, Changsha 410007, China
全文: PDF(4125 KB)   HTML
摘要: 

以NaCl+NaHSO3为腐蚀介质,通过浸渍干湿复合循环实验及腐蚀失重分析,并利用SEM,XRD和FTIR技术,研究了Q235碳钢和P265GH低合金钢的大气腐蚀行为。结果表明,两种钢的腐蚀遵从相同的动力学规律,腐蚀产物中均存在大量致密的α-FeOOH和非晶态δ-FeOOH,锈层具有很好的保护性,使得腐蚀速率降低。实验开始阶段两种钢的腐蚀量基本相同,但随着腐蚀的进行两者差距增大,P265GH低合金钢较Q235碳钢的失重小、锈层致密、耐腐蚀性好。

关键词 大气腐蚀加速腐蚀实验腐蚀产物分析    
Abstract

The corrosion behavior of P265GH low alloy steel and Q235 carbon steel under dry/humid/immersion alternative condition with NaCl and NaHSO3 were investigated by SEM, XRD, FTIR and mass loss analysis. The results show that, the relationship of mass loss to test time for the two steels fits to the same dynamics law. The corrosion products contain a large amount of dense α-FeOOH and amorphous δ-FeOOH. The resistance of rust layer make corrosion rate of the two steels decrease. The mass loss of the two steels is almost the same in the beginning stage, the difference of the mass loss become large with test time. The P265GH low alloy steel exhibited lower mass loss, denser rust layer, and better corrosion resistance rather than Q235 carbon steel.

Key wordssteel    atmospheric corrosion    accelerated corrosion test    corrosion product analysis
收稿日期: 2013-04-12     
ZTFLH:  TG172.4  
基金资助:国家电网科技项目 (KG12K16004);沈阳市科技计划项目 (F11-264-1-61) 资助
作者简介: null

王振尧,男,1962年生,博导,研究方向为材料自然环境腐蚀

引用本文:

王振尧, 于全成, 陈军君, 王军, 徐松, 胡波涛. 周期干湿浸条件下P265GH钢和Q235钢的大气腐蚀行为[J]. 中国腐蚀与防护学报, 2014, 34(1): 53-58.
Zhenyao WANG, Quancheng YU, Junjun CHEN, Jun WANG, Song XU, Botao HU. Atmospheric Corrosion Behavior of P265GH Steel and Q235 Steel under Dry/Humid/Immersion Alternative Condition. Journal of Chinese Society for Corrosion and protection, 2014, 34(1): 53-58.

链接本文:

https://www.jcscp.org/CN/10.11902/1005.4537.2013.045      或      https://www.jcscp.org/CN/Y2014/V34/I1/53

Steel C Si Mn S P Al Cu Cr Ni Ti Mo Nb V Fe
Q235 0.18 0.25 0.5 0.018 0.016 --- --- --- --- --- --- --- --- Bal.
P265GH 0.13 0.18 0.73 0.01 0.011 0.045 0.03 0.02 0.01 0.001 0.004 0.002 0.002 Bal.
  
图1  P265GH低合金钢和Q235碳钢腐蚀失重与时间的关系
图2  P265GH低合金钢和Q235碳钢腐蚀不同时间后的XRD谱
图3  P265GH低合金钢和Q235碳钢腐蚀不同时间后腐蚀产物的红外光谱
图4  P265GH钢和Q235钢经过不同时间的周期浸润腐蚀实验后的宏观形貌
图5  P265GH钢和Q235钢经过不同时间的周期浸润腐蚀实验后的微观形貌
图6  P265GH钢和Q235钢干湿浸润循环192 h的锈层截面形貌
Position O S Cl Fe Mn
A 40.53 1.80 0.18 57.48 ---
B 34.75 0.66 --- 64.60 ---
C 35.84 0.18 0.12 63.85 ---
D 34.46 0.27 0.17 65.10 ---
E 41.01 0.36 0.03 58.21 0.40
F 40.50 0.16 0.29 58.95 0.10
G 39.62 1.81 0.17 58.40 ---
H 37.16 0.42 0.12 62.30 ---
表2  P265GH低合金钢和Q235碳钢经192 h腐蚀实验后锈层的EDS分析结果
[1] Liang C F. Atmospheric corrosion of steels in China[J]. J. Electrochem., 2001, 7(2): 215-219
[1] (梁彩凤. 钢在中国大陆的大气腐蚀研究[J]. 电化学, 2001, 7(2): 215-219)
[2] Zhang A F. Influence factors of atmospheric corrosion for iron and steel[J]. Mater. Prot., 1989, 22(2): 15-16
[2] (张安富. 影响钢铁大气腐蚀的因素[J], 材料保护, 1989, 22(2): 15-16)
[3] Singh D N, Shyamjeet Y, Saha J K. Role of climatic conditions on corrosion characteristics of structural steels[J]. Corros. Sci., 2008, 50(1): 93-110
[4] Castaño J G, Botero C A, Restrepo A H, et al. Atmospheric corrosion of carbon steel in Colombia[J]. Corros. Sci., 2009, 52(3): 216-223
[5] Ma Y T, Li Y, Wang F H. The effect of β-FeOOH on the corrosion behavior of low carbon steel exposed in tropic marine environment[J]. Mater. Chem. Phys., 2008, 112(9): 844-852
[6] Ma Y T, Li Y, Wang F H. Corrosion of low carbon steel in atmospheric environments of different chloride content[J]. Corros. Sci., 2009, 51(10): 997-1006
[7] Chen H L, Wei Y. Mechanism of industrial atmospheric corrosion for carbon steel[J]. Corros. Prot., 2006, 27(6): 284-286
[7] (陈惠玲, 魏雨. 碳钢在含SO2环境大气中腐蚀机理的研究[J]. 腐蚀与防护, 2006, 27(6): 284-286
[8] Qu Q, Yan C W, Cao C N. Atmospheric corrosion of A3 steel polluted by NaCl in SO2 environment[J]. Corros. Sci. Prot. Technol., 2001, 13(S1): 432-437
[8] (曲庆, 严川伟, 曹楚南. NaCl污染的A3钢在含SO2的大气环境中的腐蚀[J]. 腐蚀科学与防护技术, 2001, 13(S1): 432-437)
[9] Misawa T, Asami K, Hashimoto K, et al. The mechanism of atmospheric rusting and the protective amorphous rust on low alloy steel[J]. Corros. Sci., 1974, 14(3): 279-289
[10] Kassim J, Baird T, Fryer J R. Electron microscope studies of iron corrosion products in water at room temperature[J]. Corros. Sci., 1982, 22(2): 147-158
[11] Ishikawa T, Kumagai M, Yasukawa A, et al. Characterization of rust on weathering steel by gas adsorption[J]. Corrosion, 2001, 57(4): 346-352
[1] 明男希, 王岐山, 何川, 郑平, 陈旭. 温度对X70钢在含CO2地层水中腐蚀行为影响[J]. 中国腐蚀与防护学报, 2021, 41(2): 233-240.
[2] 王坤泰, 陈馥, 李环, 罗米娜, 贺杰, 廖子涵. 铁细菌对L245钢腐蚀行为的影响研究[J]. 中国腐蚀与防护学报, 2021, 41(2): 248-254.
[3] 刘欣怡, 赵亚州, 张欢, 陈莉. 混凝土孔隙液中Cl-浓度对304不锈钢亚稳态点蚀的影响[J]. 中国腐蚀与防护学报, 2021, 41(2): 195-201.
[4] 张慧云, 郑留伟, 孟宪明, 梁伟. 电化学充氢对Cr15铁素体不锈钢和304奥氏体不锈钢氢脆敏感性的影响[J]. 中国腐蚀与防护学报, 2021, 41(2): 202-208.
[5] 张腾, 刘静, 黄峰, 胡骞, 戈方宇. 交变应力频率对E690钢在3.5%NaCl溶液中腐蚀电化学行为的影响[J]. 中国腐蚀与防护学报, 2021, 41(2): 226-232.
[6] 戈方宇, 黄峰, 袁玮, 肖虎, 刘静. 交变载荷频率对MS X65管线钢在H2S介质中腐蚀电化学行为影响[J]. 中国腐蚀与防护学报, 2021, 41(2): 187-194.
[7] 曹京宜, 方志刚, 李亮, 冯亚菲, 王兴奇, 寿海明, 杨延格, 褚广哲, 殷文昌. 国产镀锌钢在不同水环境中的腐蚀行为:I淡水和盐水[J]. 中国腐蚀与防护学报, 2021, 41(2): 169-177.
[8] 曹京宜, 方志刚, 冯亚菲, 李亮, 杨延格, 寿海明, 王兴奇, 臧勃林. 国产镀锌钢在不同水环境中的腐蚀行为:II反渗透水和调质水[J]. 中国腐蚀与防护学报, 2021, 41(2): 178-186.
[9] 戴婷, 顾艳红, 高辉, 刘凯龙, 谢小辉, 焦向东. 水下摩擦螺柱焊接头在饱和CO2中的电化学性能[J]. 中国腐蚀与防护学报, 2021, 41(1): 87-95.
[10] 唐荣茂, 朱亦晨, 刘光明, 刘永强, 刘欣, 裴锋. Q235钢/导电混凝土在3种典型土壤环境中腐蚀的灰色关联度分析[J]. 中国腐蚀与防护学报, 2021, 41(1): 110-116.
[11] 冉斗, 孟惠民, 刘星, 李全德, 巩秀芳, 倪荣, 姜英, 龚显龙, 戴君, 隆彬. pH对14Cr12Ni3WMoV不锈钢在含氯溶液中腐蚀行为的影响[J]. 中国腐蚀与防护学报, 2021, 41(1): 51-59.
[12] 白云龙, 沈国良, 覃清钰, 韦博鑫, 于长坤, 许进, 孙成. 硫脲基咪唑啉季铵盐缓蚀剂对X80管线钢腐蚀的影响[J]. 中国腐蚀与防护学报, 2021, 41(1): 60-70.
[13] 左勇, 曹明鹏, 申淼, 杨新梅. MgCl2-NaCl-KCl熔盐体系中金属Mg对316H不锈钢的缓蚀性能研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 80-86.
[14] 王欣彤, 陈旭, 韩镇泽, 李承媛, 王岐山. 硫酸盐还原菌作用下2205双相不锈钢在3.5%NaCl溶液中应力腐蚀开裂行为研究[J]. 中国腐蚀与防护学报, 2021, 41(1): 43-50.
[15] 张浩, 杜楠, 周文杰, 王帅星, 赵晴. 模拟海水溶液中Fe3+对不锈钢点蚀的影响[J]. 中国腐蚀与防护学报, 2020, 40(6): 517-522.