Al-Zn-In-Si合金在NaCl溶液中的小孔腐蚀行为

中国腐蚀与防护学报

1996, Vol. 16

Issue (3): 230-234

研究报告

本期目录 | 过刊浏览

Al-Zn-In-Si合金在NaCl溶液中的小孔腐蚀行为

战广深;牟战旗

大连理工大学

PITTING CORROSION BEHAVIOR OF Al-Zn-In-SI ALLOYS IN NaCl SOLUTIONS

ZHAN Guangshen; MOU Zhanqi (Dalian University of technology)

全文: PDF(1117 KB)

摘要: 研究了溶液中Ｃｌ－浓度和温度对Ａｌ－Ｚｎ－Ｉｎ－Ｓｉ和Ａｌ－Ｚｎ－Ｉｎ－Ｓｉ－Ｍｇ合金小孔腐蚀行为的影响，并利用电子探针对蚀孔进行形貌观察和线扫描分析。结果表明：Ｃｌ－浓度和温度变化对合金的阳极极化行为和孔蚀性能有较大影响；从孔蚀行为看，作为牺牲阳极，经加镁改性的合金较未加镁合金更佳。蚀孔出现在富Ｉｎ、Ｓｉ点周围，Ｃｌ－浓度较低时蚀孔底部的富Ｉｎ、Ｓｉ＂岛状物＂在浓度较高时逐渐溶解脱落，Ｉｎ、Ｓｉ在孔边缘富集。

关键词 ：铝基牺牲阳极, 小孔腐蚀, 氯离子

Abstract：The pitting potentials Eb of Al-Zn-In-Si and Al-Zn-In-Si-Mg alloys were measured in NaCl solutions.Influence of chloride ion concentration and temperature on pitting corrosion susceptibility was examined.Results showed that with the increase in Cl- concentration and temperature, the Eb decreased and pitting corrosion became more severe. From the standpiont of pitting corrosion, Al-Zn-In-Si-Mg alloy used for sacrificial anode was superior to Al-Zn-In-Si alloy. The corrosion morphology and EPA line scan analysis showed that the content of indium and silicon at pit bottom was much higher than the average content in alloy and that pitting corrosion mainly occurred around in and St-rich "islands".

Key words： Aluminium alloy Pitting corrosion Chloride ion

收稿日期: 1996-06-25

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	战广深
	牟战旗
44.8K

引用本文:

战广深;牟战旗. Al-Zn-In-Si合金在NaCl溶液中的小孔腐蚀行为[J]. 中国腐蚀与防护学报, 1996, 16(3): 230-234.
. PITTING CORROSION BEHAVIOR OF Al-Zn-In-SI ALLOYS IN NaCl SOLUTIONS. J Chin Soc Corr Pro, 1996, 16(3): 230-234.

链接本文:

https://www.jcscp.org/CN/ 或 https://www.jcscp.org/CN/Y1996/V16/I3/230

1FoleyRTCorrosion,1986,42:2772曹楚南．腐蚀用化学原理,北京:化学出版工业社,1985,p．3283SakonoT,TodaK,HandaM．MaterialsProtection,1966,5(12):454孙鸿建,火时中．中国腐蚀与防护学报,1987,7(2):1155H．克舍著,吴荫顺译．金属腐蚀,北京:化学工业出版社,1984．382

[1]	周勇, 左禹, 闫福安. 缓蚀性组分对金属小孔腐蚀的缓蚀作用与机制[J]. 中国腐蚀与防护学报, 2017, 37(6): 487-494.
[2]	金伟良,岳增国,许晨,李志远. 混凝土中钢筋脱钝氯离子阈值的快速测定[J]. 中国腐蚀与防护学报, 2012, 32(3): 223-227.
[3]	黄燕滨,宋高伟,刘学斌,丁华东,闫永贵,邵新海. Al-Zn-In-Mg-Ga-Mn牺牲阳极腐蚀防护行为研究[J]. 中国腐蚀与防护学报, 2012, 32(1): 44-47.
[4]	徐宏妍; 李延斌 . 铝基牺牲阳极在海水中的活化行为[J]. 中国腐蚀与防护学报, 2008, 28(3): 186-192 .
[5]	蒋林华 . 混凝土抗氯离子渗透扩散性研究[J]. 中国腐蚀与防护学报, 2002, 22(6): 343-348 .
[6]	阍丽静; 林海潮; 吴维tao . 含H2S的强酸性溶液中Cl-对铁腐蚀的影响*[J]. 中国腐蚀与防护学报, 1999, 19(2): 79-84 .

Viewed

Full text

Abstract

Cited

Shared

Discussed